Roadmaster Falcon 2 Tow Bar Repair Kit

Question

Question:

I mistakenly left my Falcon 2 Tow Bar exposed on my RV for the past year. Previously to this they were extending and retracting properly - now they don't. Which rebuild kit would I need, and are there instructions? Thanks!

asked by: Bart M

0

Expert Reply:

According to Roadmaster, you'll need the # RM-910003-60 Rebuild Kit for Falcon 2 Towbars.

I'll link you to the instructions, which are actually the owner's manuals for the Falcon 2 towbar. The manuals contain exploded drawings that show how the towbar goes together, which should provide plenty of information so you can repair the towbar.

expert reply by: Mike L

0

Answer 1

The repair kit that you will need for your Falcon 2 Tow Bar, #RM-520, is the Locking Pin Repair Kit, #RM-910003-80. The Autowlok feature on your tow bar is not engaging, so this repair kit will replace the inner locking mechanism which includes the…

view full answer...

Answer 2

Since your Kwikee 25 steps won't fully retract on their own it is either the motor or the gear. You will need to inspect the teeth on the gear to see if any are missing. If they are, then you need the #LC369354. If teeth are in good condition…

view full answer...

Answer 3

Your memory does serve you right and both arms on your Roadmaster Falcon 2 #RM-520 are designed to "lock up" as this is not a non-binding tow bar; whether or not they've been able to get the arms to lock without performing the two sharp…

view full answer...

Answer 4

The difference between the Class II and Class III hitches has to do with their Gross Trailer Weight (GTW), their Tongue Weight (TW), and their Hitch Receiver Size. Class II trailer hitch receivers have a 1-1/4 inch receiver and can be rated up to…

view full answer...

Answer 5

In order to determine the torque rating for the lug nuts on your trailer you will need to know check out the chart I attached that shows all of the torque specs for all the trailer lugs available based on stud size, wheel material and wheel size.

view full answer...

Answer 6

Hey Andrew! Yes, Furrion does have a Chill Cube model with a heat pump. This was actually just released for aftermarket sale. You will need a complete system to make the switch, new R32 units aren't backwards compatible with old R410A systems.…

view full answer...

Answer 7

A 4-Way trailer connector has the basic lighting functions only; running lights, left turn signal and brake lights, right turn signal and brake lights, and ground. A 7-Way has these functions and a 12 volt circuit, a circuit for electric trailer…

view full answer...

Answer 8

Hi Paul, you’re definitely on the right track here, and I can help you narrow this down with confidence. With your tandem 3,500 lb Dexter axles and 33 inch spacing, both the Dexter EZ Flex part #K71-652-00 and the Lippert Road Armor part #LC53CK are…

view full answer...

Answer 9

According to Blue Ox, it'll take an experienced installer about 4 to 5 hours to complete the installation of their #BX1128 Base Plate Kit on a 2016 Jeep Grand Cherokee. The install isn't what I'd call super-difficult, but the installation…

view full answer...

Answer 10

The OEM prep package consists of 4 "pucks" in the bed of the truck that will allow you to drop in puck style hitches for easy installation and removal, that gives you a completely clear bed when not in use. The B&W Companion OEM 5th…

view full answer...

Answer 11

Hey Melanie. The reason you can't find a replacement for your GE ARC15AACBL2 15,000 btu air conditioner is because they phased them out. In 2025 all RV AC systems had to change over to a new coolant called R32. This was a EPA mandated decision.…

view full answer...

Answer 12

It sounds like you are speaking of the wires for the brake magnets. If this is correct, you will need to connect one of the wires to the brake controller output wire on your trailer connector and the other wire will need to be grounded to a clean…

view full answer...

Roadmaster Falcon 2 Tow Bar Repair Kit

Products Featured in This Question

Product Page this Question was Asked From

Featured Help Information

Instructions

Miscellaneous Media

Continue Researching