Troubleshooting A Blown Fuse On A Demco SBS Stay-IN-Play DUO Supplemental Braking System
Updated 08/21/2023 | Published 08/18/2023
Question:
I have installed a 20 amp fuse and the fuse is still blowing after a few stops.????
asked by: Mike G
Expert Reply:
In the past, each time we've run into this issue with the Demco SBS Stay-IN-Play DUO Supplemental Braking System - Proportional # SM99251 it's always been an issue with the ground connection. I recommend checking to ensure that your ground connection is properly fixed to the chassis of your Gladiator to ensure a proper connection.
There is also the chance that your G-Force controller needs to be adjusted to prevent it from activating when stationary and blowing the fuse. I've attached a little snippet from the manual below to walk you through this.
If your fuse keeps blowing then let me know and we can troubleshoot further.
(click to enlarge)
Product Page this Question was Asked From
Demco Stay-IN-Play Duo Flat Tow Brake System for RVs w/ Hydraulic Brakes - Proportional
- Flat Tow Brake System
- Brake Systems
- Proportional System
- One-Time Setup
- Vehicle Battery
- Fixed System
- Power Assist Brake Compatible
- Hydraulic Brakes
- Indicator Lights
- Demco
more information >
Featured Help Information
Instructions
Continue Researching
- Shop: Vehicle Tow Bar Brake System
- Shop: Replacement Breakaway Switch Pin for Demco Air Force One and Stay-IN-Play Duo Braking Systems
- Q&A: Troubleshooting the Fuse Blowing on the Demco Stay-IN-Play Duo Braking System
- Shop: Trailer Wiring
- Shop: Vehicle Tow Bar Wiring
- Q&A: Wire Gauge of Demco G-Force Controller
- Video: Review of SMI - Tow Bar Braking Systems - SM99905
- Shop: Demco Stay-IN-Play Duo Flat Tow Brake System for RVs w/ Hydraulic Brakes - Proportional
- Q&A: Correct Replacement Breakaway Switch Key for the Demco Stay-In-Play Duo
- Q&A: Replacement Red Fuse for Demco Air Force One Supplemental Braking System
- Shop: Standard Fuse Kit - 5 Amps to 30 Amps - 60 Pieces
- Shop: Lippert Waste Master RV Sewer Hose w/ Leakproof Camlock and 90-Degree Nozzle - 20' Long
- Video: The Low-Down on the SmartPlug RV Power Inlet
- Shop: SmartPlug RV/Marine Data Port Inlet - Blank and Open Port - Stainless Steel
- Shop: SmartPlug RV Power Inlet and Connector - 30 Amp - Gray
- Shop: SmartPlug RV Power Inlet - 30 Amp - Black
- Q&A: Where to Drill Into the Firewall When Installing the Demco Duo Stay and Play
- Q&A: Are Additional Diodes Needed for Demco SBS Stay-IN-Play DUO Supplemental Braking System
- Article: Trailer Wiring Diagrams
- Search Results: trailer hitch
- Video: An In-Depth Look at the Roadmaster Battery Charge Line Kit for Towed Vehicles
- Shop: Trailer Hitch
- Q&A: What is the Difference Between a 4-Way and 7-Way Trailer Connector
- Search Results: trailer wiring
- Video: An In-Depth Look at the Roadmaster Diode 7-Wire to 6-Wire Flexo-Coil Wiring Kit
- Article: Brake Controller 7- and 4-Way Installation Kit (ETBC7)
- Video: Comparing Portable Flat Tow Braking Systems - Curt RVi and Blue Ox Patriot
- Article: How to Measure for Trailer Hitch Drop
- Shop: Suspension Enhancement
- Search Results: base plate for tow bar
on Flat Tow Brake System
