Assembly Time for the Demco Kar Kaddy SS

Question

Question:

How much time does this trailer take to put together? Demco Kar Kaddy SS Tow Dolly with Disc Brakes - Foldable - 4,800 lbs Item # DM9713045 I have air tools and am retired auto mechanic. Are the tires upgrades available and are the tires installed? Do we need to buy anything like brake fluid or what else? How many people are needed for assembly?

asked by: Marc P

1

Helpful Expert Reply:

I reached out to my contact at Demco and he said that the Kar Kaddy SS # DM9713045 can be assembled by 1 person and that it typically takes about 3-4 hours. If you are a retired auto mechanic then it will likely be on the lower end as you have experience with this kind of stuff. I have attached the installation details for you to check out.

It does come with all of the parts you need (aside from tools) but you will need to purchase brake fluid separately.

The tires come mounted on the wheels but you can replace them if you feel like. I recommend going with the Taskmaster ST205/75R14 Radial Trailer Tire # TR20514 if you choose to do so. This tire has a load range C (1,760 lbs at 50 psi) and a speed rating of 81 mph. Please note that the instructions for the Kar Kaddy say not to exceed 55 mph though.

If you have any other questions please don't hesitate to ask.

expert reply by: Jon G

1

John

4/8/2024

Jon, I am considering purchasing the SS Kar Kaddy, with Disc Brakes. Do you have a video of how to assemble the trailer once delivered? Also, I do not like the recommended limited 55 MPH tow speed (tires). When towing it is not unusual to reach 70 to 75 mph when going downhill in our Motorhome. What tire would would you recommend we upgrade to? Also, should we opt for a wider rim and tire at the same time? Thanks, John

Jon G.

4/9/2024

@John I reached out to my contact at Demco and the 55 MPH speed rating they have the Kar Kaddy SS Tow Dolly with Disc Brakes # DM9713045 rated for has more to do what they believe is a safe speed for users to abide by. If you were to install the Provider ST205/75R14 Radial Trailer Tire - Load Range C # TR20514 that I initially posted about then it would ensure the tires are rated for a higher 81 MPH speed rating, but you would be doing so "at your own risk" since Demco says otherwise.

John B.

4/9/2024

@JonG Thanks, Jon, I do not routinely drive any faster than 60 to 65 MPH in my motorhome. While pulling a trailer it is difficult to keep the speed down to or below 60 MPH when going downhill. Therefore, I want to make sure the tires are rated at or above 65 MPH so during those few times I exceed 60 MPH I am assured the tires will handle the speed. If I decide to purchase this Tow Dolly, I will have to upgrade the tires before hitting the road. Thanks, John

Jon G.

4/9/2024

@JohnB Thanks for the clarification! If 60-65 MPH is your max then I can assure you that the tires that come on the tow dolly can handle those speeds. All industry-standard trailer tires nowadays can go up to at least 65 MPH. I had just reached out about the higher 70-75 MPH rating you initially asked about and that's why I received the reply from my contact that I did.

Answer 1

Demco has an interesting way to determine if the Kar Kaddy X #DM9713093 would provide enough ground clearance for a vehicle like your 2006 Mini Cooper to load. You will need to measure from where the front wheel touches the ground on front side of…

view full answer...

Answer 2

To ensure you do not damage the air dam on your 2014 VW Beetle there are a few measurements you will need to make. First you will need to measure the ground clearance of your air dam from the ground. If this is less than 3.5" you will not be…

view full answer...

Answer 3

I looked up the dimensions of your High Pointe EC942K9E and it's 15 inches deep, 15.7 inches tall, and 29.9 inches wide so the Furrion Over the Range RV Convection Microwave #FMCM15SS that you referenced would easily fit in place of it and would…

view full answer...

Answer 4

The Tulga T10 D2 5th Wheel Hitch is more for semi-tractor applications and has a pretty big draw-back in that you cannot adjust the hitch head height which is critical for fifth wheel towing because you need to be as level as possible or you will…

view full answer...

Answer 5

For your RAM 8000 Series jack #TJD-7000S, you can use the Replacement Sidewind Handle for etrailer and Ram Square, Direct Weld Jacks #TJD-7000S-HD for a replacement handle and handle pin. If by pin you were actually referring to the footplate keeper…

view full answer...

Answer 6

When it comes to choosing between the Blue Ox Patriot #BLU37TR and the Brake Buddy Select 3 #HM39524, these systems are extremely similar in their setup and functionality. Both of these systems provide proportional braking in a compact and easy to…

view full answer...

Answer 7

You're not going to have any problems mixing Dexter and Lippert components on trailer axles over 10k-lbs in the same manner as below 10k-lbs as long as the measurements on the replacement parts are the same- i.e. bearing sizes are the same, etc..…

view full answer...

Answer 8

The wiring for the 7-Pin connector is different than the 7-Way blade connector. You will need an adapter to make the two different styles compatible. You can use the Adapter 7 Way (Blade) to 7 Way (Round Pin), #47595. The blade end plugs into the…

view full answer...

Answer 9

From what we have found, the Nissan factory brake controller harness has the following color/functions: Nissan Red to brake controller black for 12-volt power Nissan Red with green tracer to controller red for input from stoplight Nissan black to…

view full answer...

Answer 10

Thanks for reaching out! The replacement brake pads for your Demco Kar Kaddy SS #DM9713045 can be found as part #DM59VR on our site. This includes parts for both sides of the tow dolly. If you want to replace the whole assembly then you can do so by…

view full answer...

Answer 11

In most states a tow dolly like the Demco Kar Kaddy SS Tow Dolly with Disc Brakes part #DM9713045 does not need to be licensed and tagged, but many require that the tow dolly be titled and registered. The towed vehicle however must be licensed as its…

view full answer...

Answer 12

If the steering stabilizer shock on your Demco Kar Kaddy SS Tow Dolly part #DM9713045 has gone bad then the wheels on the tow dolly may shimmy a bit while driving down the road or you will see oil around where the shock mounts as this would point to…

view full answer...

Assembly Time for the Demco Kar Kaddy SS

Products Featured in This Question

Product Page this Question was Asked From

Featured Help Information

Instructions

Miscellaneous Media

Continue Researching