Replacement Brake Linings/Shoes for Hayes/AL-KO 185100-150 12-Inch Trailer Brake Assemblies

Question

Question:

I have a set of Hayes/AL-KO Electric Trailer Brake Kit - 12inch - Left and Right Hand Assemblies - 7,000 lbs Item # 185100-150 on my trailer and would like to replace the shoes. The magnets and drums are fine. Can you direct me to the replacement parts that I need? Thanks, GS

asked by: Greg

0

Expert Reply:

The replacement brake shoe and lining for the Hayes/AL-KO # 185100-150 brake assembly is part # BP04-185, which includes shoes/linings for one wheel. The hold down springs/pins for one wheel is part # BP06-090.

expert reply by: Mike L

0

Answer 1

The Hayes/AL-KO Electric Brake Assembly, part #185100-150 is designed to replace Kelsey Hayes brake assemblies with 5-bolt mounting pattern, and is used with a 12 inch hub/drum. This includes both the left-hand and the right-hand side. We do not…

view full answer...

Answer 2

You likely have an 8 on 6-1/2 bolt pattern which is normally found on 5,200 pound axles to 10,000 pound axles. The majority of axles with this bolt pattern are 7,000 pound axles. If you could pull off a hub and tell me the numbers stamped on the…

view full answer...

Answer 3

It sounds like you are speaking of the wires for the brake magnets. If this is correct, you will need to connect one of the wires to the brake controller output wire on your trailer connector and the other wire will need to be grounded to a clean…

view full answer...

Answer 4

If you already have brake drums you will not have to replace them unless they are damaged or became overheated and have discoloration on the inside armature surface where the magnet rides, grooves in the armature surface, or severe wear where the…

view full answer...

Answer 5

For your Coachmen Camper you are going to want the Dexter Electric Trailer Brake Kit #23-105-106 for an exact replacement to both the left and right brake assemblies that you currently have. Our part number dropped the -00 at the end. The Dexter…

view full answer...

Answer 6

It could be a tow package fuse on the vehicle. Use the owners manual to find the locations of fuses/relays related to the tow package wiring to check them and replace as needed. If the issue is not a fuse or relay then you can test the vehicle side…

view full answer...

Answer 7

It sounds like you have the brake mounting flange for Hayes/AL-KO brakes. The standard 5-bolt brake mounting pattern on #AKEBRK-6 will not work. We do have brakes that have that mounting pattern though. You will need #23-105-09 for the left and…

view full answer...

Answer 8

To determine the size of the brake assemblies you need you have to measure the depth and width of the hub drum on the axle like what you see in the picture I attached. The most common size is 2-1/4 inch wide like the #T4071600-500 that you…

view full answer...

Answer 9

We have what you are looking for. To replace the parts 363233.1 and 363233.2 you would want the part #185100-150. These are the exact same as the parts you are looking for. These are 12 inch by 2 inch assemblies with a 7,000 lb capacity.

view full answer...

Answer 10

The 2K Torque Ramp Spring #RS16933RH is an industrial strength spring. It is designed for up to 90 degrees of deflection, but most people by hand can cause no deflection at all. It is designed to be used with the LH #RS16933LH, and is for heavy ramps…

view full answer...

Answer 11

You will need to do some measuring to determine if the 10 Inch Electric Brake Assembly LH, item #AKEBRK-35L, is the correct assembly for your trailer. Measure the diameter of the mounted brake shoe, the width of the lining and the distance between…

view full answer...

Answer 12

That's a very good question, we tend to be extra cautious and say to use 10 gauge wire because that would be more than enough. When you get into longer trailers that will end up using a lot of wire the heavier gauge wire becomes more necessary.…

view full answer...

Replacement Brake Linings/Shoes for Hayes/AL-KO 185100-150 12-Inch Trailer Brake Assemblies

Products Featured in This Question

Continue Researching