Low Voltage on 7-Way of 2017 Ford F-250 Super Duty
Updated 08/17/2020 | Published 08/13/2020
Products Featured in This Question
Question:
Testing a 7 pin plug on the truck I get good power out of the the turn signal lugs and brake but barely any power out of the trailer lights lug. Do you know what would cause that.
asked by: Dan I
Expert Reply:
There are a couple things that may be causing the low voltage you are seeing on the 7-way of your 2017 Ford F-250 Super Duty. The first is a poor ground, so check to ensure the ground is good as this can cause the issue you are having.
The other likely problem is corrosion on the pins of the 7-way so you will want to check to see if the pins have corrosion and either clean them or replace the 7-way with the Curt T-Connector Vehicle Wiring Harness # C55774 or 7- and 4-Pole Trailer Connector Socket # HM40975.
Also, to ensure corrosion does not occur in the future, it is highly recommended that you always use Dielectric Grease for Electrical Connectors # 11755.
Product Page this Question was Asked From
Curt T-Connector Vehicle Wiring Harness for Factory Tow Package - 7-Way and 4-Pole Flat Connectors
- Custom Fit Vehicle Wiring
- Trailer Hitch Wiring
- Vehicle End Connector
- No Converter
- Factory Tow Package
- 4 Flat
- 7 Blade
- Plug and Lead
- Plug-In
- CURT
more information >
Featured Help Information
Instructions
Miscellaneous Media
Continue Researching
- Shop: Trailer Wiring
- Q&A: Troubleshooting Trailer Brake Module Fault on 2008 Ford F-250 w/ a Factory Controller
- Q&A: Recommended Exterior Light For An Enclosed Trailer That Runs Off Of 110V
- Video: Trailer Wiring Harness Installation - 2008 Ford F-250 HM40975-11998
- Shop: TecNiq Low Profile Stop Tail Turn Light - 15.5" - Clear Lens
- Shop: TecNiq Slim Line Accent Surface Mount Light - 36" - Blue/White LEDs - Black Aluminum
- Shop: Optronics LED Trailer License Plate Light - Submersible - 3 Diodes - Grey Housing - Clear Lens
- Shop: Optronics LED Trailer License Plate Light - 5 Diodes - Chrome Plated - Clear Lens
- Shop: LED Identification Light Bar for Trailers over 80" Wide - Submersible - 3 Diodes - Clear Lens
- Shop: Opti-Brite LED Utility Light - Aluminum Housing - Oblong -19-5/8" Long
- Shop: Red Identification Light Bar with White LED Utility Light - 17 Diodes - 15-1/2" x 1"
- Q&A: How to Bypass Smart Tow Feature of Ford Trailer Wiring for 12 Volt Accessory Circuit
- Video: Hands-On with the Dragon's Eye LED Clearance or Side Marker Light
- Q&A: How to Ground Lights When Re-Wiring Aluminum Frame Snowmobile Trailer
- Article: Trailer Lighting Requirements
- Search Results: dragon eye
- Video: What to Know About the Dragon's Eye LED Clearance or Side Marker Light
- Article: Trailer Wiring Diagrams
- Q&A: Should There Be Continuity Between Running Lights And Ground Circuit While Bulb Is Disconnected
- Search Results: dragons eye
- Q&A: What is the Difference Between a Class II and a Class III Hitch?
- Search Results: trailer hitch
- Shop: Trailer Hitch
- Article: Brake Controller 7- and 4-Way Installation Kit (ETBC7)
- Search Results: trailer wiring
- Q&A: Lug Nut Torque Chart for Trailer Wheels
- Search Results: trailer tires and wheels
- Shop: Suspension Enhancement
- Article: Wiring Trailer Lights with a 7-Way Plug (It's Easier Than You Think)
- Search Results: trailer jack
on Custom Fit Vehicle Wiring
