Replacement Balloon Wheels for the Malone Xpress TRX-S Kayak Beach Cart

Question

Question:

Are there replacement tires for this cart?

asked by: Chase

0

Expert Reply:

Yes! To replace the tires on your Malone Xpress TRX-S Kayak Beach Cart with Balloon Wheels # MAL54GR you just need the following:

- Replacement Balloon Tire Beach Wheels # MPG516

expert reply by: Jon G

0

Bill S.

8/3/2026

Hello., yes I spoke to one of your sales representatives who was very helpful in answering my questions related to part number MPG 516. I have additional questions. I’am curious to know if you sell a wheel bushing reducer. For Part # MPG516 from 20.5mm., I see is appox. 2 1/16” I.D OEM axle opening. Which is fairly large opening for an axle. In-order for Beach Wheels to fit a 5/8” O.D. axle. I particularly like the wheel because it’s an offset wheel and no other company sells that particular wheel for my application in an offset. Please advise.,Thanks Bill

Claire H.

8/3/2026

@BillS The Malone Ballon Beach Wheels part # MPG516 are specifically designed for Malone beach cart axles, so they don't have a reducer sleeve for using them with smaller 5/8" axles. You would need to have a custom-machined reducer bushing made by a local machine shop or bearing supplier in order to adapt it to the size you're needing.

Bill S.

8/4/2026

@ClaireH Thanks Claire., I also should correct a mistake on the size opening of the wheel axle 20.5mm. I see that it’s closer to 13/16” Dia. I’am not a fan of millimeters, when converting to drill bit size. I believe they may work if I can find the correct axle wheel bushing. My other question is if this is a two piece wheel?..Judging by the six octagon holes., I’am assuming that it is?..when looked at the picture I assumed this could also be for a six hole axle hub attachment. Could you clarify. Thank you

Claire H.

8/4/2026

@BillS Yes, the Malone Replacement Balloon Beach Wheels part # MPG516 is two pieces. The six holes you see in the hub are where the screws hold the plastic hub assembly together around the balloon tire's bladder. Since they're have screws inside them, they're not meant to be used to attach the tires to a hub assembly.

Answer 1

I did some research on your 2021 Hobie Outback, and the hull measures 34 inches wide. For a width of 34 inches, the Malone MegaWing Fishing Kayak Carrier with Tie-Downs #MPG207 will be able to carry it on a crossbar system. If you wish for me to…

view full answer...

Answer 2

The difference between the Class II and Class III hitches has to do with their Gross Trailer Weight (GTW), their Tongue Weight (TW), and their Hitch Receiver Size. Class II trailer hitch receivers have a 1-1/4 inch receiver and can be rated up to…

view full answer...

Answer 3

In order to determine the torque rating for the lug nuts on your trailer you will need to know check out the chart I attached that shows all of the torque specs for all the trailer lugs available based on stud size, wheel material and wheel size.

view full answer...

Answer 4

Hey Andrew! Yes, Furrion does have a Chill Cube model with a heat pump. This was actually just released for aftermarket sale. You will need a complete system to make the switch, new R32 units aren't backwards compatible with old R410A systems.…

view full answer...

Answer 5

A 4-Way trailer connector has the basic lighting functions only; running lights, left turn signal and brake lights, right turn signal and brake lights, and ground. A 7-Way has these functions and a 12 volt circuit, a circuit for electric trailer…

view full answer...

Answer 6

Hey Dale, thanks for reaching out. For your 2010 Toyota Tundra with the factory tow package, a proportional controller is definitely the way to go for smooth braking on a 2-axle trailer, and a really clean option is the Redarc Tow-Pro Liberty…

view full answer...

Answer 7

Hello Joe, Thanks for writing in! Based on the measurements you provided, the Gen-Y Glyder Shock Absorbing Ball Mount #325-GH-12001 is not the right fit for your setup. Since your Tundra's receiver measures 18 inches from the ground and your TAB…

view full answer...

Answer 8

Hello John, thanks for reaching out. Yes, the mounting holes on the TecNiq Contoured Seven Function Box Style Tail Light #TN42XR (driver side) and #TN62XR (passenger side) are exactly the same as the Wesbar 271595 tail light. They are 2" apart…

view full answer...

Answer 9

Hey Peter. The Malone Xpress TRX-S Kayak Beach Cart item #MAL54GR includes two balloon tires that measures 12" diameter x 7" wide when fully inflated. This carrier has a 150 lbs capacity and measures 36" wide x 6" long x 31"…

view full answer...

Replacement Balloon Wheels for the Malone Xpress TRX-S Kayak Beach Cart

Products Featured in This Question

Product Page this Question was Asked From

Featured Help Information

Instructions

Miscellaneous Media

Continue Researching