Why Is My AirLift WirelessONE Blowing the In-Line Fuse On My 2020 Ford F-350?
Updated 09/27/2025 | Published 04/22/2023
Question:
I have the airlift wireless one single path kit on my 2020 Ford F350 Dually. Been on the truck for 3 years and just this week it has started blowing the 20 amp in-line fuse connected to the positive side of the battery. Without the truck on it takes a few minutes for the fuse to pop. Start the truck and use either the remote or my iPad app to control it and the fuse immediately pops. Any help would be appreciated. Thank you.
asked by: Kenneth B
Expert Reply:
It sounds like you may need to check out your wiring on your Air Lift WirelessONE Compressor System for Air Helper Springs # AL25980.
Considering that it worked fine before, and now blows fuses that leads me to believe your wiring is the issue. It could also be a bad compressor, but I would first make sure that your wiring is good. Check to make sure that your grounds are clean, (free from rust/debris) not loose, and there are no exposed wires.
If your wiring is good, check next to make sure your unit is being supplied the proper voltage. If there is too much power going to your unit the fuse will pop to protect frying the unit.
Finally, if that all is good then you'd just need to replace your compressor.
Brad S.
9/27/2025
Hi there, just installed the 7500 resr bags, 2 gal tank chrome airlift compressor and easy mount wireless smart unit. All meticulously wired and triple verified. Fired up, compressor ran and ran. Couldn't get the unit to pump up bags. I pulled fuse. Tank had plenty of pressure. I released pressure to start over. 30 amp Fuse was blown. Replaced fuse, blew I'm 2 seconds. To eliminate compressor issue, I cut hot lead. Put fuse back in. Blew again. The only thing left is the control unit and wire harness. Ill be call Etrailer or Airlift Monday morning. Anything more to check? ....thx Brad
Product Page this Question was Asked From
Air Lift WirelessONE Compressor System for Air Helper Springs - Remote - Bluetooth - Single Path
- Air Bag Compressor Kit
- Smartphone App
- Wireless Remote
- Single Path
- Digital Display
- No Tank
- Light Duty
- Air Lift
more information >
Featured Help Information
Instructions
Continue Researching
- Video: Installing the Air Lift WirelessONE Compressor System on a 2019 Ford F-250 Super Duty
- Shop: Air Lift WirelessONE Compressor System for Air Helper Springs - Remote - Bluetooth - Single Path
- Shop: Air Lift LoadLifter 7500 XL Ultimate Air Helper Springs - Rear Axle
- Shop: Pacbrake Basic In-Cab Air Control Kit w/ Analog Gauge - Independent Air Spring Control
- Shop: Pacbrake Premium Air Tank and Accessories Kit - Black Carbon Steel - 1/2 Gallon
- Search Results: safety chain
- Search Results: extended shank
- Video: Detailed Breakdown of the Firestone Air Command Standard Duty Air Compressor
- Shop: SumoSprings Trailer Helper Springs w/ Line Relocation Bracket - Single Axle - 5K to 8K - Overslung
- Shop: Firestone Air Command Heavy Duty Air Compressor with Tank - Analog - Single Path
- Shop: Air Lift Load Controller II Compressor System for Air Helper Springs - Single Path
- Video: What to Know About the Equal-i-zer Weight Dist Shank
- Q&A: Solution for Needing Longer Extension with Recurve WD System to Allow Tailgate to Open
- Search Results: bulletproof hitches hitch adapters
- Search Results: drop hitch
- Video: BulletProof Hitches 2-Ball Mount for 2-1/2" Hitch Spec Review
- Video: All About the Gen-Y Adjustable 2-Ball Mount w/ Stacked Receivers
- Video: Complete Breakdown of the BulletProof Hitches 2-Ball Mount for 2-1/2" Hitch
- Q&A: Air Lift Compressor Keeps Blowing 15 amp Fuse - What Can I Do?
- Video: Hands-On with the Aluminum Liger Trailer Wheel
- Search Results: step
- Search Results: wheel bearing
- Search Results: wheel bearing kit
- Shop: RV Jack Pads
- Q&A: How To Pair an Air Lift WirelessAIR Remote to Compressor
- Q&A: Troubleshooting Air Lift WirelessOne Compressor System Remote Not Pairing
- Q&A: Comparing Air Springs And Jounce Springs For A 2022 Chevy Silverado DRW 4x4
- Article: Best Air Bag Suspension (2023)
- Q&A: Which Air Bags Will Work With A B&W Gooseneck Installed In A 2007 Ford F-250?
- Q&A: Comparing Pacbrake to Firestone and Air Lift Air Bags
on Accessories and Parts
Larry
5/18/2024
My 15amp in line fuse to my wireless ONE compressor just started suddenly blowing. All the wires look good. How do I check if compressor is bad. Any other suggestions would help and be appreciated.