Why Is My AirLift WirelessONE Blowing the In-Line Fuse On My 2020 Ford F-350?
Updated 09/27/2025 | Published 04/22/2023
Question:
I have the airlift wireless one single path kit on my 2020 Ford F350 Dually. Been on the truck for 3 years and just this week it has started blowing the 20 amp in-line fuse connected to the positive side of the battery. Without the truck on it takes a few minutes for the fuse to pop. Start the truck and use either the remote or my iPad app to control it and the fuse immediately pops. Any help would be appreciated. Thank you.
asked by: Kenneth B
Expert Reply:
It sounds like you may need to check out your wiring on your Air Lift WirelessONE Compressor System for Air Helper Springs # AL25980.
Considering that it worked fine before, and now blows fuses that leads me to believe your wiring is the issue. It could also be a bad compressor, but I would first make sure that your wiring is good. Check to make sure that your grounds are clean, (free from rust/debris) not loose, and there are no exposed wires.
If your wiring is good, check next to make sure your unit is being supplied the proper voltage. If there is too much power going to your unit the fuse will pop to protect frying the unit.
Finally, if that all is good then you'd just need to replace your compressor.
Andrew
5/31/2024
Bad check valve can cause the compressor to overwork and blow fuse as well
Brad S.
9/27/2025
Hi there, just installed the 7500 resr bags, 2 gal tank chrome airlift compressor and easy mount wireless smart unit. All meticulously wired and triple verified. Fired up, compressor ran and ran. Couldn't get the unit to pump up bags. I pulled fuse. Tank had plenty of pressure. I released pressure to start over. 30 amp Fuse was blown. Replaced fuse, blew I'm 2 seconds. To eliminate compressor issue, I cut hot lead. Put fuse back in. Blew again. The only thing left is the control unit and wire harness. Ill be call Etrailer or Airlift Monday morning. Anything more to check? ....thx Brad
Product Page this Question was Asked From
Air Lift WirelessONE Compressor System for Air Helper Springs - Remote - Bluetooth - Single Path
- Air Bag Compressor Kit
- Smartphone App
- Wireless Remote
- Single Path
- Digital Display
- No Tank
- Light Duty
- Air Lift
more information >
Featured Help Information
Instructions
Continue Researching
- Shop: Suspension Enhancement
- Shop: Air Lift WirelessONE Compressor System for Air Helper Springs - Remote - Bluetooth - Single Path
- Video: Review of DeeMaxx Trailer Bearings Races Seals Caps - Replacement Caps - DE69NR
- Search Results: air lift compressor
- Video: Review of ESCO Trailer Breakaway Kit - ES34FR
- Video: Installing the Air Lift WirelessONE Compressor System on a 2019 Ford F-250 Super Duty
- Video: Detailed Breakdown of the Firestone Air Command Standard Duty Air Compressor
- Shop: SumoSprings Trailer Helper Springs w/ Line Relocation Bracket - Single Axle - 5K to 8K - Overslung
- Search Results: dexter 8 201
- Shop: Fastway Zip Trailer Breakaway Switch with Coiled Cable - 6' Long
- Shop: ESCO Alarmed Breakaway Switch
- Shop: Pacbrake Premium Air Tank and Accessories Kit - Black Carbon Steel - 1/2 Gallon
- Shop: Air Lift Load Controller Compressor System for Air Helper Springs- Heavy Duty - Single Path
- Shop: Firestone Ride-Rite Air Helper Springs - Double Convoluted - Rear Axle
- Q&A: Solution for Needing Longer Extension with Recurve WD System to Allow Tailgate to Open
- Video: What to Know About the Equal-i-zer Weight Dist Shank
- Search Results: safety chain
- Search Results: extended shank
- Q&A: Air Lift Compressor Keeps Blowing 15 amp Fuse - What Can I Do?
- Q&A: Troubleshooting Air Lift WirelessONE Compressor System Remote Not Finding System
- Video: Install: Firestone Ride-Rite Red Label Extreme Duty Air Helper Springs on a 2022 GMC Sierra 2500
- Video: BulletProof Hitches 2-Ball Mount for 2-1/2" Hitch Spec Review
- Q&A: Replacement Wheel Studs For 6,000LB Axle With 1/2"-20 Threaded Studs 2-3/4" Long
- Q&A: Wheel Stud Recommendation to Fit Dexter 7,000 lb Hubs
- Search Results: bulletproof hitches hitch adapters
- Search Results: drop hitch
- Q&A: Troubleshooting Air Lift WirelessOne Compressor System Remote Not Pairing
- Q&A: Should I Get Loadlifter 5000 Or 7500 For Towing A 15K Fifth Wheel
- Article: Best Air Bag Suspension 2025
- Article: Choosing the Right Suspension Kit for Your Truck and Trailer
on Accessories and Parts
Larry
5/18/2024
My 15amp in line fuse to my wireless ONE compressor just started suddenly blowing. All the wires look good. How do I check if compressor is bad. Any other suggestions would help and be appreciated.