Self Adjusting Brake Assemblies to Replace B12E-22

Question

Question:

we are working on a 2 axle trailer and i believe that it is a 7k axle looking for brake kits/drums, the label on the brake backing plate is a B12E-22 / AXLE TEK 12GG i think it is a 12x2 brake with 5 bolt mounting want to change it to the self adjusting brakes both sides L and R ALSO looking for the complete brake drums which are 8 lug. Do you have these in complete kits?

asked by: James J

1

Helpful Expert Reply:

The brake assemblies you have now are the # AKEBRK-6 so for a self-adjusting setup you'd want the part # 23-458-459. Then for a 7k hub with an 8 lug bolt pattern you'd want the part # AKHD-865-7-2-EZ-K.

expert reply by: Jameson C

1

Answer 1

The correct set of replacement brake assemblies for your AxleTek 12 inch assemblies is the kit part #AKEBRK-7-SA that you referenced. This kit is a pair of left and right assemblies that are an exact match to what you have that are also self…

view full answer...

Answer 2

I'd be happy to help! For replacement brake assemblies you'll need (2) of the #AKEBRK-7-SA for 4 total assemblies (2 axles), but for the correct hubs you'll need to know your bolt pattern The hub options are: 6 on 5-1/2"…

view full answer...

Answer 3

The Optronics LED Clearance or Side Marker Trailer Light is available in Red #MCL0030RBB and Amber #MCL0030ABB. These are the closest replacements to the Glo Brite 122r/122y lights you have. The lights only have one LED diode versus the 3 in your…

view full answer...

Answer 4

I do have an option but Glo-Brite is no longer in business so you won't be able to get any replacement parts for these lights such as lenses. The only option you have would be a full replacement for which the most similar option we offer is the…

view full answer...

Answer 5

In order to determine the torque rating for the lug nuts on your trailer you will need to know check out the chart I attached that shows all of the torque specs for all the trailer lugs available based on stud size, wheel material and wheel size.

view full answer...

Answer 6

According to Blue Ox, it'll take an experienced installer about 4 to 5 hours to complete the installation of their #BX1128 Base Plate Kit on a 2016 Jeep Grand Cherokee. The install isn't what I'd call super-difficult, but the installation…

view full answer...

Answer 7

It sounds like you are speaking of the wires for the brake magnets. If this is correct, you will need to connect one of the wires to the brake controller output wire on your trailer connector and the other wire will need to be grounded to a clean…

view full answer...

Answer 8

The #84 spindle is just a common way to identify the spindle dimensions typically used for 3,500 lb axles. So instead of listing out the parts, people can just say they have #84 spindles and it's easier to know what fits it. The CE Smith Trailer…

view full answer...

Answer 9

Even though I cannot comment specifically on the grease you used because I am not familiar with it, I can tell you the best grease for trailer bearings is a a grease with a rating of GC-LB, which just means it is made to withstand very high…

view full answer...

Answer 10

The Demco Hydraulic Trailer Brake Actuator part #DM72VR should be a direct replacement for the Atwood 61101 Brake Actuator that you have now. This newest updated it rated at 7K instead of 6K. This is a bolt on option that mounts on 3" centers.…

view full answer...

Answer 11

That's a very good question, we tend to be extra cautious and say to use 10 gauge wire because that would be more than enough. When you get into longer trailers that will end up using a lot of wire the heavier gauge wire becomes more necessary.…

view full answer...

Answer 12

The etrailer.com Electric Trailer Brake Kit #AKEBRK-7-SA and the Dexter Nev-R-Adjust Electric Brake Kit # 23-464-465 referenced in your question are both self-adjusting assemblies that will work to replace the existing Dexter brakes on your 7,000…

view full answer...

Self Adjusting Brake Assemblies to Replace B12E-22

Products Featured in This Question

Product Page this Question was Asked From

Continue Researching