Progressive Dynamics Power Converter/Smart Charger Overcharging Troubleshooting
Updated 04/13/2021 | Published 04/10/2021
Products Featured in This Question
Question:
I have a 90 amp progressive dynamics electrical panel in my 40 ft fifth wheel. My batteries are charging in absorb mode at 14.6 volts. I’m assuming converter is bad. Do I have to replace entire panel or can I just replace a circuit board Ty.
asked by: Jim
Expert Reply:
It sounds like you're stuck in Boost Mode because it's trying to charge a bad battery. I would first try swapping the battery and run another voltage test to see if it falls back down.
If you find that it's still stuck in Boost Mode then you can replace the converter with Replacement Converter Section for Progressive Dynamics 4500 Series RV Power Control Center - 90 Amp Item # PD4590CSV.
Product Page this Question was Asked From
Progressive Dynamics 4500 Series RV Converter w/ Charge Wizard and AC/DC Distribution Panel - 90 Amp
- RV Power Converter
- Converter and AC/DC Panel
- Battery Mode Switch
- 12V
- 90 Amps
- AGM
- Gel
- Lead Acid
- Lithium
- Multi-Stage Charge
- Progressive Dynamics
more information >
Featured Help Information
Instructions
Miscellaneous Media
Continue Researching
- Shop: Brake Controller
- Shop: Champion 4,000-Watt Portable Inverter Generator - Gas - Manual Start - CO Shield - RV Ready
- Shop: Replacement Converter Section for Progressive Dynamics Inteli-Power 4000 Series 45 Amp Power Center
- Shop: Progressive Dynamics Replacement Section for AC/DC Power Distribution Panel - 45 Amp
- Shop: Replacement Converter Section for Progressive Dynamics Inteli-Power 4500 Series 75 Amp Power Center
- Shop: Curt TriFlex NEXT Trailer Brake Controller w/ Custom Harness - 1 to 4 Axles - Proportional
- Q&A: Replacement Converter Section for PD4590K18NS2
- Q&A: Electrical Panel Box With AC To DC Converter For RV / Cargo Trailer Remodel
- Q&A: Do You Have to Replace the Converter Section of a PD4590 Power Center For Lithium Batteries
- Q&A: Will Progressive Dynamics PD4590CSV Work With Lithium
- Q&A: Recommended AC/DC Distribution Panel And Charger For A 2006 Forest River Sierra Sport T34SP
- Q&A: Can Converter Section for 4590K18L be Upgraded to Lithium Batteries if it Doesn't Have an Li Switch?
- Q&A: Replacing Converter On A WFCO WF-9990 Power Converter With Distribution Panel
- Article: 30-Amp and 50-Amp RV Service: What's the Difference?
- Article: Trailer Wiring Diagrams
- Article: Best RV Roof Vents
- Article: Wiring Trailer Lights with a 7-Way Plug (It's Easier Than You Think)
- Article: How to Raise Your Travel Trailer Height
- Article: Brake Controller 7- and 4-Way Installation Kit (ETBC7)
- Article: Ugly RV Makeover: How to Change Outdated RV Lighting