Proper Position of Equalizer and Shackles on Trailer Suspension

Question

Question:

I just installed new Springs hangers equalizers. Are these shackles on The Equalizer suppose to be up?

asked by: Jr. L

0

Expert Reply:

I attached a picture that shows the proper position of shackles and equalizers on trailer suspension. Sometimes the shackle will flip up but if you jack up the trailer by the axle that's got the shackle flipped you can usually get it to flip back over.

expert reply by: Jameson C

0

click to enlarge

Answer 1

The suspension in general on your trailer looks very worn. I would replace as much as I could on it to get it back to good working order. The problem with the equalizer cocked to one side like that can happen sometimes. It usually fixes itself when a…

view full answer...

Answer 2

If the shackles are flipping the wrong direction frequently that typically means the leaf springs are too short, the hanger spacing is too big, or the shackles are too short. Most of the time it's somebody changed leaf springs and just went with…

view full answer...

Answer 3

Ff the springs you are installing are 25-1/4 inches, you would need to place the hangers between 24-3/4 and 25 inches apart. The shackle should be angled as the drawing shows in the attached helpful article, which should be toward the rear of the…

view full answer...

Answer 4

The shackles on your equalizers should be pointing up when the trailer is under its weight on the ground, and will only point down like you mentioned when the trailer is in the air and the axles are off the ground. It is pretty common for one side of…

view full answer...

Answer 5

There isn't an exact angle to go off of when it it comes to shackle straps, but we try to them to sit in a 'W' shape to allow for the suspension to travel without binding up. Depending on the length of the shackle straps the angle can…

view full answer...

Answer 6

You can use leaf springs that are rated higher than the axle without any issues as long as they measure the correct measurement for your trailer. For example the 6-leaf double eye spring for 7,000 lb axles part #e64SR measures 24-7/8" eye to…

view full answer...

Answer 7

The determine the correct replacement leaf spring on your 2021 Coachmen 259FKDS you'll need to lift your trailer frame so the spring is hanging freely and then measure from center-eye to center-eye, then for the equalizer you need to measure…

view full answer...

Answer 8

Ideally you can get the measurement of your axle by using a precision instrument like a digital caliper similar to Item #PTW80157. There is also often a sticker or a tag on your trailer axle that tells you the weight capacity of your axle which can…

view full answer...

Answer 9

Sounds like one of your shackles is facing the wrong direction after installing everything. When a shackle flips around and faces the wrong direction on trailer suspension most of the time just putting weight on the trailer and driving will correct…

view full answer...

Answer 10

Having the shackles below the equalizer would put the leaf spring out of level. Also, the equalizer wouldn't want to function properly and most likely the shackle would end up flipping over to the top of it or binding up/putting undue stress on…

view full answer...

Answer 11

It is not uncommon for the trailer hangers on a tandem axle trailer to be all the same size or for there to be different sizes that can be 1-1/2 to 2 inches different in height when you compare the center hanger to the front and rear. For example,…

view full answer...

Answer 12

In order for your trailer suspension to function properly you will want the angle of the shackle strap to be towards the axle so that as the leaf spring compresses and expands it will have somewhere it can go. Otherwise, you will not get the optimum…

view full answer...

Proper Position of Equalizer and Shackles on Trailer Suspension

Product Page this Question was Asked From

Continue Researching