Does Hydrastar Actuator Run All The Time When Breakaway Pin is Pulled
Updated 02/23/2026 | Published 02/14/2026
Question:
I just I stalled the hydra star unit on my double axel boat trailer with disc brakes. One question I have which has been asked before I believe is , does the pump run continuously after the breakaway pin is pulled even after reaching full pressure? The other question is can you reverse bleed the system? Are there any valves in the system that will prevent the brake fluid from traveling from the calipers to the reservoir? Thank you, Dan
asked by: Daniel
Expert Reply:
Hey Daniel, yes the Hydrastar actuator part # HS381-8067 that you referenced would run continuously once the pin of the breakaway has been pulled. This is why a battery is part of the breakaway system as it needs that to power the system. Also, yes the system can be reverse bled if needed. Do you have a surge brake setup currently?
Product Page this Question was Asked From
Hydrastar Marine Electric Over Hydraulic Actuator for Disc Brakes - 1,600 psi
- Brake Actuator
- Electric-Hydraulic Brake Actuator
- Boat Trailer
- Travel Trailer
- Disc Brakes
- Hydrastar
more information >
Continue Researching
- Q&A: Does The Hydrastar Brake Actuator HBA16 Need To Be Bled Manually?
- Q&A: Comparing Hydrastar Electric Over Hydraulic Versus Hydrastar Marine Electric Over Hydraulic Actuator
- Q&A: Troubleshooting Electric Over Hydraulic Braking System that Uses Hydrastar Actuator
- Q&A: How to Bleed Trailer Brakes with Electric-Over-Hydraulic Brake Actuator
- Q&A: Troubleshooting Hydrastar HBA 16 Electric over Hydraulic Trailer Brake Actuator that Runs Constantly
- Q&A: Do Hydrastar Electric Over Hydraulic Actuators Run All the Time When Brakes Are Applied
- Shop: Hydrastar Marine Electric Over Hydraulic Actuator for Disc Brakes - 1,600 psi
- Q&A: DeeMax Disc Brake Kit Recommendation for 2022 Grand Design Solitude 310
- Article: Trailer Wiring Diagrams
- Article: Wiring Trailer Lights with a 7-Way Plug (It's Easier Than You Think)
- Article: Breakaway Kit Installation for Single and Dual Brake Axle Trailers
- Article: Holiday 2025 | Best Gifts for Towers
- Article: How to Replace Trailer Leaf Springs in 5 Steps
- Article: Adding Electric Over Hydraulic Disc Brakes
- Article: Trailer Lighting Requirements
Daniel
2/20/2026
I did have a surge break system but I removed it and installed the Hydrastar with disc brakes . I replaced the rusted out drum brakes as I frequently launch the boat in salt water. . I’m excited to try this new system. Thanks for all your help at E trailer.