Dexter Electric Over Hydraulic Actuator Runs Constantly and Goes Through Brake Fluid Fast
Updated 07/15/2015 | Published 07/14/2015
Question:
My actuator runs constantly, and goes through fluid, can not find any leak
asked by: Jimmy M
Expert Reply:
That fluid has to be going somewhere! What you can do is have someone activate the manual override on the brake controller in the vehicle cab while checking for leaks. Make sure the reservoir is full though.
If it is not leaking at a line or connection somewhere then check the wheels cylinders at the brake assemblies. You might also notice brake fluid on the backs of the wheels or in that general area. You want the brakes to be applied full so make sure the controller is set to the maximum output.
If you still can't find the leak then it is possible that it is leaking into the actuator # K71-651 body which would mean that either you would have to send it in to Dexter for repairs or replace it.
Product Page this Question was Asked From
Dexter DX Series Electric Over Hydraulic Brake Actuator for Disc Brakes - 1,600 psi
- Brake Actuator
- Electric-Hydraulic Brake Actuator
- Boat Trailer
- Travel Trailer
- Disc Brakes
- Dexter
more information >
Featured Help Information
Instructions
Continue Researching
- Shop: Dexter DX Series Electric Over Hydraulic Brake Actuator for Disc Brakes - 1,600 psi
- Q&A: Troubleshooting A Dexter DX Series Disc Brake Actuator That's Not Activating The Brake Assemblies
- Q&A: Comparing Dexter DX, BrakeRite II, and Hydrastar Electric-Over-Hydraulic Actuators
- Shop: DeeMaxx Alpha G1600 Electric Over Hydraulic Actuator for Disc Brakes - 1,600 psi
- Shop: Deutsche Hydrapro Alpha G-1600X Electric Over Hydraulic Disc Brake Actuator - 1,600 psi - 28.7 oz
- Shop: Deutsche Hydrapro Alpha G-1600 Electric Over Hydraulic Actuator for Disc Brakes - 1,600 psi
- Shop: Deutsche Hydrapro Alpha G-1000 Electric Over Hydraulic Actuator for Drum Brakes - 1,000 psi
- Shop: Hydrastar Vented Marine Electric Over Hydraulic Actuator for Disc Brakes - OEM - 1,600 psi
- Shop: Combination LED Trailer Tail Light - Submersible - 6 Function - 11 Diodes - Passenger Side
- Search Results: #84 spindle
- Shop: Trailer Wiring
- Search Results: mcl13
- Shop: Mud Flaps
- Search Results: mesh tarp
- Search Results: oval light box
- Q&A: Determining Which Spare Tire and Carrier Fits 2016 Aluma 638LW Utility Trailer
- Search Results: jb10~170
- Search Results: ramp door springs
- Search Results: junction box
- Shop: Roof Rack
- Video: The Low-Down on the Dexter DX Series Electric Over Hydraulic Brake Actuator for Disc Brakes
- Q&A: No Power on 12-Volt Accessory Pin on 7-Way of 2005 Chevy Silverado
- Q&A: Troubleshooting Dexter Electric Over Hydraulic Trailer Brake Actuator Cycles On and Off
- Q&A: Dexter Electric Over Hydraulic Actuator Runs But Does Not Build Pressure
- Q&A: Troubleshooting Dexter Electric Over Hydraulic Actuator that Runs When Disconnected
- Article: Trailer Wiring Diagrams
- Shop: Trailer Hitch
- Article: Brake Controller 7- and 4-Way Installation Kit (ETBC7)
- Shop: Suspension Enhancement
- Article: How to Measure for Trailer Hitch Drop
on Brake Actuator
