Recommended Timbren Axle-less System for a 2023 Intech Luna Rover

Question

Question:

Im looking to upgrade the suspension on my 2023 Intech Luna Rover. Not looking to raise or lower the height. Is this version of the timbren 3500lb HD correct for my travel trailer?

asked by: James

0

Expert Reply:

Hey James yes, the Timbren Axle-Less Trailer Suspension # TASR35HDS04 is the correct axle-less system for your 2023 Intech Luna Rover.

This system has a 3,500 lb capacity, a 5 bolt mounting flange, and will work with tires ST235/85R16 or smaller.

If there is something else I can do to help you, please feel free to drop a comment!

expert reply by: Bryce D

0

Lazer S.

10/27/2025

Hey James, how did the Timbren axle-less suspension work out on your Intech Luna Rover? Your experience could point others in the right direction.

Answer 1

The Jeep JL Wrangler wheel bolt pattern is 5 on 5 inch which we do have a way to accomplish what you are wanting. For a hub that has a 5 on 5 inch bolt pattern to fit the spindles of the Timbren axle less kit part #ASR3500S06 you would want the…

view full answer...

Answer 2

There will be an option for a lift kit for your 2021 Forest River R-Pod 171, though that depends on the configuration of the torsion axle. We know that these trailers use the Lippert torsion axles, though you'll need to take a look at see if…

view full answer...

Answer 3

The difference between the Class II and Class III hitches has to do with their Gross Trailer Weight (GTW), their Tongue Weight (TW), and their Hitch Receiver Size. Class II trailer hitch receivers have a 1-1/4 inch receiver and can be rated up to…

view full answer...

Answer 4

In order to determine the torque rating for the lug nuts on your trailer you will need to know check out the chart I attached that shows all of the torque specs for all the trailer lugs available based on stud size, wheel material and wheel size.

view full answer...

Answer 5

A 4-Way trailer connector has the basic lighting functions only; running lights, left turn signal and brake lights, right turn signal and brake lights, and ground. A 7-Way has these functions and a 12 volt circuit, a circuit for electric trailer…

view full answer...

Answer 6

According to Blue Ox, it'll take an experienced installer about 4 to 5 hours to complete the installation of their #BX1128 Base Plate Kit on a 2016 Jeep Grand Cherokee. The install isn't what I'd call super-difficult, but the installation…

view full answer...

Answer 7

Both the Roadmaster and Blue Ox tow bars are great options. But if it was my decision to make I would go with the Blue Ox Avail part #BX7420 as we have found that the Blue Ox tow bars are a little easier to connect and disconnect from. Also this tow…

view full answer...

Answer 8

Hi Paul, you’re definitely on the right track here, and I can help you narrow this down with confidence. With your tandem 3,500 lb Dexter axles and 33 inch spacing, both the Dexter EZ Flex part #K71-652-00 and the Lippert Road Armor part #LC53CK are…

view full answer...

Answer 9

That's a very good question, we tend to be extra cautious and say to use 10 gauge wire because that would be more than enough. When you get into longer trailers that will end up using a lot of wire the heavier gauge wire becomes more necessary.…

view full answer...

Answer 10

It sounds like you are speaking of the wires for the brake magnets. If this is correct, you will need to connect one of the wires to the brake controller output wire on your trailer connector and the other wire will need to be grounded to a clean…

view full answer...

Answer 11

The #84 spindle is just a common way to identify the spindle dimensions typically used for 3,500 lb axles. So instead of listing out the parts, people can just say they have #84 spindles and it's easier to know what fits it. The CE Smith Trailer…

view full answer...

Answer 12

Hello again, Dan. Thanks for writing in. The Demco Stay IN Play DUO Inline Air Pressure Regulator #DM88UV will not be needed for your 2025 Maverick Hybrid. You can still install one to lessen the braking pressure if it seems too harsh, but it…

view full answer...

Recommended Timbren Axle-less System for a 2023 Intech Luna Rover

Product Page this Question was Asked From

Featured Help Information

Instructions

Continue Researching