Parts Needed To Add Hydraulic EOH Disc Brakes to Boat Trailer with 5,200 lb - 6,000 Lb Axle
Question:
I have a 2002 venture dual axle boat trailer, currently only has single axle surge brakes, looking to convert to 4 wheel disc with electric over hydraulic. it is currently 6 lug, dexter brakes and hubs on the rear. has a 5 bolt flange and pretty sure its the #42 spindle, info tag is worn off trailer. hauls a 30 foot, roughly 7,500lb boat. can you point me in the right direction? will only travel twice a year and stored indoors when not in use. thank you!
asked by: Eric S
Expert Reply:
The Kodiak Disc Brake Kit part # K2HR526D is just what you need to add disc brakes on a boat trailer with 5,200 lb - 6,000 lb axles. That said, I would also order four of the the following grease seals as your axle could use either and you won't know till you tear apart the hubs, the Double Lip Grease Seal part # GS-2125DL. In order to complete the setup you'll also need the HydraStar Electric Over Hydraulic Actuator Kit for Disc Brakes part # HBA16-252-82.
I have attached a few videos I did installing the above parts as well
Products Referenced in This Question
Grease Seal - Double Lip - 2.125" ID - 3.376" OD - GS-2125DL
- Trailer Bearings Races Seals Caps
- Seals
- Grease Seals - Double Lip
- 2.125 Inch I.D.
- 3.376 Inch O.D.
- etrailer
more information >
Hydrastar Electric Over Hydraulic Actuator Kit for Disc Brakes - 1,600 psi
- Brake Actuator
- Electric-Hydraulic Brake Actuator
- Marine
- Travel Trailer
- Disc Brakes
- Hydrastar
more information >
Product Page this Question was Asked From
Kodiak Disc Brake Kit - 12" Hub/Rotor - 6 on 5-1/2 - Dacromet - 5,200 lbs to 6,000 lbs
- Accessories and Parts
- Trailer Brakes
- Disc Brakes
- LH
- RH
- 5200 lbs
- 6000 lbs
- Brake Assembly
- 6 on 5-1/2
- Hub and Rotor Assembly
- Kodiak
more information >
Featured Help Information
Instructions
Miscellaneous Media
Continue Researching
- Shop: Hydrastar Marine Electric Over Hydraulic Actuator w/ Breakaway and 7-Way RV Harness - 1,600 psi
- Video: All About the #42 E-Z Lube Spindle w/ Flange for 5.2K to 7K Trailer Axles
- Shop: Hydrastar Marine Electric Over Hydraulic Actuator w/ Breakaway and 7-Way RV Harness - 1,200 psi
- Video: Full Disc Brake Conversion Installation - 2020 Jayco Pinnacle Fifth Wheel
- Shop: Kodiak Hydraulic Brake Hose - FIF and 90-Degree Male Fittings w/ Stainless Flares - 1.5'
- Shop: Hydrastar Electric Over Hydraulic Actuator for Disc Brakes - 1,600 psi
- Q&A: Which Trailer Electric Over Hydraulic Actuator is the Best
- Search Results: hs381~9067
- Search Results: kodiak 225 brake pads
- Video: An In-Depth Look at the Karrier ST225/75R15 Radial Trailer Tire with 15" Galvanized Wheel
- Search Results: 225/75/r15
- Search Results: 12 drum
- Q&A: Can 1600 PSI Pressure from Actuator be Used with Drum Brake Assemblies
- Q&A: Can I Replace the Bolt in My Surge Coupler to Secure it in Place?
- Q&A: Replace Trailer Surge Coupler with Straight Coupler on a Trailer With Surge Brakes
- Shop: #42 E-Z Lube Spindle w/ Flange for 5.2K to 7K Trailer Axles - 2-1/4" Diameter
- Shop: Steel Spoke Trailer Wheel - 15" x 6" Rim - 6 on 5-1/2 - Galvanized Finish
- Shop: DeeMaxx Hydraulic Brake Line - Rubber - 3/16" Brass Male Inverted Flares - 1' Long
- Search Results: brake hose
- Q&A: How to Choose Replacement 7,000 lb Trailer Axle
- Video: HydraStar Marine Electric Over Hydraulic Actuator Installation
- Video: Hydrastar Brake Actuator - Electric-Hydraulic Brake Actuator - HS381-9067 Review
- Q&A: Replacement Master Cylinder for a Titan Model 60 Drum Trailer Brake Actuator
- Q&A: Brake Controller Compatibility with EOH Trailer Brake Actuators
- Article: Adding Electric Over Hydraulic Disc Brakes
- Search Results: electric over hydraulic brakes
- Article: Trailer Wiring Diagrams
- Search Results: brake actuator
- Shop: Trailer Hitch
- Shop: Trailer Wiring
on Accessories and Parts
