Can I Upgrade My 35A Converter to an 80A Converter for Lithium Batteries?
Updated 09/12/2025 | Published 05/21/2025
Products Featured in This Question
Question:
I have a progressive Dynamics PD 4135 power center that currently has a 35 amp converter. Id like to upgrade the converter as it takes far too long to charge my 200 amp hour lithium battery bank, but keep the power center in place for AC breakers/ DC distribution panel and fuses. Can I simply disable the converter in this power center by removing the charge line to the battery and add the PD89RR instead? Does any of the AC wiring need to be up sized from a typical 15a circuit to accommodate the PD89RR?
asked by: Arik
Expert Reply:
Hey Arik, thanks for reaching out!
Since the 80A Progressive Dynamics 9300 Series RV Converter Charger # PD89RR is rated quite a bit higher than the current 35A converter in your setup, you'll have to swap over the entire power center to something with a higher rating like the 75A # PD4575K18LS8 or 90A # PD4590K18LS8.
This is something we've reached out to Progressive Dynamics about in the past and they've said the whole power center needs an upgrade in order to do this safely. You won't need to upgrade the wiring though.
Are you planning on installing this on your own?
Product Page this Question was Asked From
Progressive Dynamics 9300 Series RV Converter Charger - 12V - 80A
- Power Converter
- Converter Only
- Manual Switch
- 12V
- 80 Amps
- AC to DC
- AGM
- Lead Acid
- Lithium
- RV
- Single-Stage Charge
- Progressive Dynamics
more information >
Continue Researching
- Shop: Progressive Dynamics 9300 Series RV Converter Charger - 12V - 80A
- Search Results: rv power converter
- Video: Review of Progressive Dynamics RV Power Converter - Standard Charge - PD89RR
- Search Results: progressive dynamics
- Shop: Progressive Dynamics 9300 Series RV Converter Charger - 12V - 60A
- Shop: Go Power RV Converter and Smart Battery Charger - 12V - 75 Amp
- Shop: Portable Power Watchdog Surge Protector with Bluetooth and WiFi - 50 Amp
- Article: RV Roof Types: What Type of Roof Does My RV Have?
- Q&A: What Does the 75 AMP Go Power RV Converter and Smart Battery Charger Plug Into?
- Q&A: Can a Higher Amp RV Converter Be Used for Replacement
- Q&A: Replacing 65 Amp RV Power Converter with Lithium Compatible Converter/Battery Charger
- Search Results: coleman mach soft start
- Q&A: Charger PD PD79RR for single 560ah lithium battery?
- Video: Review of Progressive Dynamics RV Power Converter - Standard Charge - PD79RR
- Shop: Portable Power Watchdog Surge Protector with Bluetooth, WiFi, and Emergency Shut Down - 30 Amp
- Shop: Portable Power Watchdog Surge Protector with Bluetooth, WiFi, and Emergency Shut Down - 50 Amp
- Shop: Progressive Dynamics 9300 Series RV Converter Charger - 12V - 45A
- Video: Let’s Check Out the LED Bullet Clearance or Side Marker Trailer Light with Grommet
- Article: 7 Steps to Clean Your RV Awning, Prevent Mold, and Save Money
- Search Results: 7 pin trailer wiring kit
- Search Results: rv transfer switch
- Search Results: slide topper
- Search Results: distribution panel
- Q&A: Can I Add the NOCO Genius On-Board Battery Charger to a System with an Existing Charger
- Q&A: Could Progressive Dyanamics Converter PD4045KA be Replaced with PD4060K
- Q&A: Recommended Battery For Current Inverter & Solar Panel Setup
- Article: Trailer Wiring Diagrams
- Shop: Trailer Hitch
- Shop: Trailer Wiring
- Video: Redarc Tow-Pro Liberty Brake Controller Review RED24FR
on Power Converter
Jon G.
9/12/2025
Hey Arik, did you decide to upgrade the entire power center to accommodate the new converter? I'm asking because your experience could help others considering a similar upgrade.