What to Consider When Converting Single Axle Trailer to Tandem Axle
Updated 08/23/2017 | Published 08/22/2017
Question:
I have a 1995 Trail-Rite single-axle 3700 GVWR trailer. I would like to convert to a tandem axle 5000 GVWR. I see many conversion kits but I am not sure which one to get. Any suggestions? Thanks!
asked by: Angel G
Expert Reply:
You can convert a single axle trailer to a tandem axle but it's more extensive than just putting the extra axle on there. The current axle does need to be repositioned for proper tongue weight. You will also need to cut off the current hangers since the hanger spacing will not be the same. I've attached a chart that you can use to determine the axle placement.
You'll need to the axle's weight capacity and diameter as well as the length and type of springs. Then we can determine exactly which parts you'll need to complete the job.
You'll also need to replace the fenders with tandem axle fenders which we do not carry.
I've attached some links to our selection of parts that you'll need as well.
Product Page this Question was Asked From
Tandem-Axle Trailer Hanger Kit for Double-Eye Springs - 1-1/2" Front/Rear, 2-1/2" Center
- Trailer Suspension Parts
- Hangers
- Suspension Kits
- Boat Trailer
- Camper
- Car Hauler
- Snowmobile Trailer
- Utility Trailer
- Double Eye Springs
- Tandem Axle
- etrailer
more information >
Featured Help Information
Miscellaneous Media
Continue Researching
- Shop: Brophy Vertical Tool Holder for E Track - 2" Inner Diameter
- Search Results: latch
- Search Results: butt hinge
- Search Results: mcl95as
- Search Results: tailights
- Search Results: screw trim cover
- Shop: Butt Hinge w/ Non-Removable Pin - 3" Long x 3" Wide - 3/16" Pin Diameter - Steel
- Search Results: toggle switch
- Search Results: 2~5/16 inch ball coupler adjustable trailer coupler
- Shop: Trailer Wiring
- Shop: V-Shaped Identification Light Bar for Boat Trailers - Submersible - Red LEDs - Red Lens
- Shop: Kenda 205/65-10 Bias Trailer Tire with 10" Galvanized Wheel - 5 on 4-1/2 - Load Range E
- Shop: Dexter Trailer Axle Beam with E-Z Lube Spindles - 86-1/2" Long - 6,000 lbs
- Shop: Wireless Side Marker Light AHD Cameras for Brandmotion Wireless HD Observation Camera System
- Shop: Replacement 4 Pin Harness for Brandmotion Wireless Transparent Trailer Systems - 65' Long
- Video: Review of DeeMaxx Rubber Hydraulic Brake Line 280 Inch - DE94JR
- Q&A: Troubleshooting Disc Brakes with Aero-6000 on Four Winns Boat Trailer Dragging/Overheating
- Shop: Brake Controller
- Shop: Trailer Hitch
- Shop: Camper Tie-Downs
- Shop: Fifth Wheel Hitch
- Video: Complete Breakdown of the 4-Leaf Double-Eye Spring for 5,000-lb Trailer Axles
- Shop: Floor Mats
- Video: Let’s Check Out the Dexter DX7.5L A-60 Brake Actuator w Electric Lockout
- Video: The Low-Down on the Dexter DX Series Electric Over Hydraulic Brake Actuator for Disc Brakes
- Article: Double-Eye Trailer Suspension System Review
- Q&A: Replacement Gray Fenders for EZ Loader Boat Trailer
- Video: Let’s Check Out the CE Smith U-Bolt Kit for Mounting Round Trailer Axles
- Article: Where to Position the Trailer Axle?
- Video: Comprehensive Review: T-Style Hook and Keeper Door Holder for RV or Enclosed Trailer
on Trailer Suspension Parts
