Troubleshooting Hitch Lock that Won't Turn All the Way to Release

Question

Question:

the lock seems frozen, cannot get the key to turn more than a quarter in , what can I do to get the lock off.

asked by: Gregory C

0

Expert Reply:

I would recommend hitting the lock with some WD40 to try and get the lock core to release. Use the straw that comes with it to direct the lube into the core as much as possible. You may have to let it soak for a few minutes.

Working the key in and out of the core several times can help it penetrate and free up the stuck portion of it.

expert reply by: Jameson C

0

Jimmy

6/6/2024

What if the editors-40 want work. How do you get the tumble off

Jameson C.

6/6/2024

@Jimmy Time to bust out the sawz-all then...

Answer 1

After a long period in place a lock mechanism can stick and make it tough to get the key in it, or to get the inserted key to turn. There are a few suggestions I can offer to you to get your lock #1480DAT open. You can spray a bit of aerosol white…

view full answer...

Answer 2

Sounds like your Masterlock locking hitch pin part #2848DAT has some frozen tumblers. I would recommend using the straw of your WD40 can to direct it into the lock core as much as possible. Then use the good key to help get it into the lock core. To…

view full answer...

Answer 3

I can certainly help you out. The hardware used on the Thule Adventurer is #TH04997 that you have referenced. There is a specific order in which all of the parts will go on the crossbars. I have included a picture that shows how all of the parts go…

view full answer...

Answer 4

I'm not 100% sure which locking hitch pin you have but it sounds like a complete failure of the mechanism. This doesn't happen very often but it is possible. I would try spraying some WD-40 up into the lock if you can where it meets the hitch…

view full answer...

Answer 5

Sounds like the internal ball-bearings on your Bulldog Lifelong Trigger-Style Coupler Lock and 2" Trailer Hitch Receiver Lock, #BD580404, may be stuck. Try using a penetrating spray lubricant, like the UltraLube Biobased Spray Lubricant and…

view full answer...

Answer 6

The difference between the Class II and Class III hitches has to do with their Gross Trailer Weight (GTW), their Tongue Weight (TW), and their Hitch Receiver Size. Class II trailer hitch receivers have a 1-1/4 inch receiver and can be rated up to…

view full answer...

Answer 7

A 4-Way trailer connector has the basic lighting functions only; running lights, left turn signal and brake lights, right turn signal and brake lights, and ground. A 7-Way has these functions and a 12 volt circuit, a circuit for electric trailer…

view full answer...

Answer 8

Hey Jonathon thank you so much for all of that additional information! To haul your bikes behind your class C Sprinter motorhome, while flat towing your Mini, I recommend the Hollywood Racks RV Rider Bike Rack item #HLY64FR and the Roadmaster Dual…

view full answer...

Answer 9

Good morning Brett, Yes, the Curt Spectrum Brake Controller w/ Custom Harness - Dash Mounted Knob #C28SV and the Curt Echo Under-Dash Bluetooth Brake Controller w/ Custom Harness #C46GV will both work just fine in your 2026 Ram 1500 Rebel. They are…

view full answer...

Answer 10

To install a Redarc Tow Pro Liberty in your 2023 Toyota Tacoma Sport you will need the following parts: Redarc Tow-Pro Liberty Brake Controller item #RED24FR Plug-and-Play Wiring Harness for Redarc Tow-Pro Trailer Brake Controllers item #RED99FR…

view full answer...

Answer 11

That's a very good question, we tend to be extra cautious and say to use 10 gauge wire because that would be more than enough. When you get into longer trailers that will end up using a lot of wire the heavier gauge wire becomes more necessary.…

view full answer...

Answer 12

Hey Jeff, thanks for reaching out. Yes, the Curt Echo Wireless Brake Controller #C51180 will absolutely work on your 2026 Ram 1500 Rebel. As long as it has the factory 7-way, the echo unit will work just fine. I'm not 100% sure why we don't…

view full answer...

Troubleshooting Hitch Lock that Won't Turn All the Way to Release

Featured Help Information

Miscellaneous Media

Continue Researching