Installation of Replacement Endcap for Thule AeroBlade Edge Roof Rack
Updated 01/27/2026 | Published 08/24/2024
Question:
Whats the secret to properly installing the TH1500052333s and locking them on? Almost every time I try, the lock doesnt go in far enough and it ends up pushing the end cap off the tower when attempting to rotate to locking position. Ive spend multiple sessions trying and for some unknown reason the angle is right sometimes, and the lock turns fine. I currently have two locks in place after 60+ minutes of fiddling with the other two, I end up taping them to the towers so they wont blow off. I still lost a cover!
asked by: Mike R
Expert Reply:
Hi Mike; I'm sorry these are giving you so much trouble but I don't have any secret installation method for the # TH1500052333 on your roof rack. The best I can say is to make sure you get it aligned properly as you push them on. Since the angle is right sometimes when you do this I would try to make sure you replicate it for the others. I went ahead and attached an installation video below for you to check out. You can see where the endcaps were installed starting at 4:30 in the video.
Product Page this Question was Asked From
Replacement Endcap for Thule AeroBlade Edge Roof Rack - Flush Fixed - Left
- Accessories and Parts
- Roof Rack
- End Caps
- 1 Pack
- Thule
more information >
Featured Help Information
Miscellaneous Media
Continue Researching
- Search Results: yakima rack and roll
- Search Results: thule
- Search Results: thule bike rack
- Search Results: thule roof box
- Search Results: thule straps
- Q&A: Replacement EndCaps For Thule WingBar Evo Crossbars That Thule Hullavator Clamps To
- Shop: Replacement Endcap for Thule WingBar Evo Crossbars - Left Side
- Shop: Thule Portage Canoe Carrier w/ Tie-Downs - Gunwale Brackets - Side Loading
- Shop: Thule SUP and Surfboard Pads for Square Crossbars - 30" Long - Qty 2
- Shop: Replacement Straps for Thule JawGrip Paddle, Oar, or Mast Holder - Qty 2
- Shop: Replacement Endcap for Thule WingBar Evo Crossbars - Right Side
- Shop: Yakima Kayak Trailer for 5 Kayaks - 250 lbs
- Shop: Thule SUP Shuttle Stand-Up Paddleboard Carrier with Tie-Downs - Roof Mount - 2 Boards
- Search Results: thule wind deflector
- Q&A: Replacement End Caps for Thule AeroBlade Edge Roof Racks
- Search Results: thule aeroblade edge
- Q&A: What Crossbar Spread Can Thule Motion XT XL Cargo Box Fit On
- Q&A: Which Lock Core Do I Need For My Thule AeroBlade Edge Roof Rack?
- Q&A: Is Replacement End Cap Correct For Thule AeroBlade 60 Crossbar
- Q&A: Comparing Thule AeroBlade Crossbars vs WingBar Evo Crossbars
- Q&A: Replacement Endcap for Thule AeroBlade Crossbars SOA567X020
- Shop: Trailer Hitch
- Article: Trailer Wiring Diagrams
- Article: Brake Controller 7- and 4-Way Installation Kit (ETBC7)
- Shop: Trailer Wiring
- Article: How to Measure for Trailer Hitch Drop
- Shop: Suspension Enhancement
- Shop: Brake Controller
- Video: An In-Depth Look at the Roadmaster Battery Charge Line Kit for Towed Vehicles
- Article: Wiring Trailer Lights with a 7-Way Plug (It's Easier Than You Think)
on Accessories and Parts
Robin H.
1/27/2026
Hey Mike, were you able to get the endcaps on your Thule roof rack to lock in place after watching that video? Knowing what worked could help others who run into the same alignment issue.