How to Wire the Titan BrakeRite EHB Electric-Hydraulic Actuator for Disc Brakes Part # T4813100

Question

Question:

What amp circuit breaker to protect actuator power source?

asked by: Thomas

0

Expert Reply:

The Titan BrakeRite EHB Electric-Hydraulic Actuator for Disc Brakes part # T4813100 will need to receive power from a 12 volt battery with a 40 amp circuit breaker like part # 9510 placed 6" from the positive battery terminal. I have attached a wiring diagram for you as well.

The newest model of this is the Titan BrakeRite I Plug and Play Electric-Hydraulic Actuator Kit # T4813102.

expert reply by: Conner L

0

click to enlarge

Answer 1

Hello Stephen, thanks for reaching out. I am sorry to say that Dexter does not offer a replacement control board for the BrakeRite unit. The entire unit will need to be replaced. Which BrakeRite unit is it exactly? Is it the plug-in version or is it…

view full answer...

Answer 2

Yes, the Replacement Plug and Play Electric-Over-Hydraulic Actuator #DX36XR is the correct part for your Dexter BrakeRite II SD. To replace the wiring harness you also need part #T4834300. This is the harness with the 7-Way connectors and the…

view full answer...

Answer 3

Hey Gregg, yes you can use the Dexter BrakeRite Electric Over Hydraulic Actuator for Disc Brakes #DX82KR to replace your Replacement Dexter BrakeRite II SD Electric Over Hydraulic Actuator #DX36XR. The only difference is like you already stated, the…

view full answer...

Answer 4

You will want to start by following the troubleshooting tips in the manual for the electric over hydraulic actuator, #K71-651. I have outlined them here for you: 1. Verify that the trailer and tow vehicle are wired according to the electrical…

view full answer...

Answer 5

In order to determine the torque rating for the lug nuts on your trailer you will need to know check out the chart I attached that shows all of the torque specs for all the trailer lugs available based on stud size, wheel material and wheel size.

view full answer...

Answer 6

The difference between the Class II and Class III hitches has to do with their Gross Trailer Weight (GTW), their Tongue Weight (TW), and their Hitch Receiver Size. Class II trailer hitch receivers have a 1-1/4 inch receiver and can be rated up to…

view full answer...

Answer 7

According to Blue Ox, it'll take an experienced installer about 4 to 5 hours to complete the installation of their #BX1128 Base Plate Kit on a 2016 Jeep Grand Cherokee. The install isn't what I'd call super-difficult, but the installation…

view full answer...

Answer 8

It sounds like you are speaking of the wires for the brake magnets. If this is correct, you will need to connect one of the wires to the brake controller output wire on your trailer connector and the other wire will need to be grounded to a clean…

view full answer...

Answer 9

The #84 spindle is just a common way to identify the spindle dimensions typically used for 3,500 lb axles. So instead of listing out the parts, people can just say they have #84 spindles and it's easier to know what fits it. The CE Smith Trailer…

view full answer...

Answer 10

A 4-Way trailer connector has the basic lighting functions only; running lights, left turn signal and brake lights, right turn signal and brake lights, and ground. A 7-Way has these functions and a 12 volt circuit, a circuit for electric trailer…

view full answer...

Answer 11

Even though I cannot comment specifically on the grease you used because I am not familiar with it, I can tell you the best grease for trailer bearings is a a grease with a rating of GC-LB, which just means it is made to withstand very high…

view full answer...

Answer 12

That's a very good question, we tend to be extra cautious and say to use 10 gauge wire because that would be more than enough. When you get into longer trailers that will end up using a lot of wire the heavier gauge wire becomes more necessary.…

view full answer...

How to Wire the Titan BrakeRite EHB Electric-Hydraulic Actuator for Disc Brakes Part # T4813100

Products Featured in This Question

Product Page this Question was Asked From

Featured Help Information

Instructions

Continue Researching