Upgraded Equalizer for 2010 Keystone Cougar Travel Trailer With 4,400 Pound Axles

Published 05/19/2022

Products Featured in This Question

Equa-Flex Cushioned Equalizers - Double Eye Springs - Tandem Axle - 3K to 6K

(239)

$246.51

MORryde Suspension Upgrade Kit for Tandem Axle Trailers - 2-1/4" Long Shackle Straps

(1958)

$125.09

MORryde Suspension Upgrade Kit for Tandem Axle Trailers - 3-1/8" Long Shackle Straps

(1958)

$119.44

Question:

Ok, my axle spread is 35” Center to center, and my lower bolts on the equalizer is roughly 7” Center to Center, leaf width is 1 3/4” but my shackle are roughly 3 1/4”.

asked by: Marv W

Expert Reply:

If you would like to add the Equa-Flex to your 2010 Keystone Cougar you will need the # LC279687. The # LC279688 is designed for 6,000-8,000 lb axles so it would be overrated for your trailer. The # LC279687 is for 3,000-6,000 lb axles. You will want to measure the eye to eye length of your existing equalizers to make sure this is a good fit for your trailer.

The # LC279687 measures 5-1/2" long. As long as your measurement is close to this then it will work well for an upgrade. If your equalizer is significantly longer then you will need a different system that also fits with your axle capacity. More than likely these will work for you.

For wet bolts, bronze bushings, and heavy duty shackles I recommend the MORryde Suspension Upgrade Kit for Tandem Axle Trailers. The correct kit will depend on the length of your current shackles. If you have 2-1/4" shackles then you need the # MR46ZR. For 3-1/8" shackles you will need the # MR76ZR instead.

I have attached some installation videos along with a link to all of our upgraded equalizers for tandem axle trailers. I also included a helpful article on trailer suspension which shows all of the different measurements for you to check out.

expert reply by: Robin H

Marv W.

5/19/2022

Ok, my axle spread is 35” Center to center, and my lower bolts on the equalizer is roughly 7” Center to Center, leaf width is 1 3/4” but my shackle are roughly 3 1/4”.

Robin H.

5/19/2022

I reached out to Lippert and based on your equalizer measurements you will want to go ahead and go with the higher rated # LC279688. It sounds like based on your shackle measurements you need the # MR76ZR with the 3-1/8" shackles. With your 35" axle spacing you may also want to consider the MORryde Premium Rubber Suspension Kit for Tandem Axle Trailer - 35" Wheelbase # MR47ZR. The upgraded equalizers in this kit combined with the Steel X-Factor crossmember will significantly improve your ride along with the stability of your frame. This also helps to extend the life of your trailer.