Brake Fluid Leaking Around Master Cylinder Fill Cap On Titan Aero 6000 Surge Brake actuator
Updated 07/30/2021 | Published 07/28/2021
Question:
I have a question regarding the cap for a TITAN aero 6000 actuator. Specifically does it have some sort of pressure release or bypass function? The actuator seems to be leaking fluid around the cap and I cant see how it is getting out of the cap.
asked by: Del
Expert Reply:
The Master Cylinder Filler Cap # T4480701 on your Titan Aero 6000 brake actuator does have a small pin hole that works with the diaphragm in the cap to release excess pressure in the reservoir. It may be that either fluid is leaking from this hole in the cap or that the rubber o-ring on the cap is damaged allowing fluid to get past.
If your rubber o-ring is damaged and causing the leak you should just replace the cap and o-ring at the same time. This will reduce the risk of the diaphragm in the cap being bad as well or going out on you shortly after.
Product Page this Question was Asked From
Replacement Master Cylinder Filler Cap for Dexter Model 60 and Aero 7500 Actuators
- Accessories and Parts
- Brake Actuator
- Disc Brakes
- Hydraulic Drum Brakes
- Master Cylinder
- Cap
- Dexter
more information >
Continue Researching
- Search Results: trailer brake kits
- Search Results: 10 36 seal
- Article: 4 Reasons Not to Use RV Solar Power (And 4 Reasons You Should)
- Article: Trailer Wiring Diagrams
- Shop: Rich Solar RV Solar Charging Kit w/ 6 Panels - 12V - 1,200 Watts
- Shop: etrailer 12V Power RV Patio Awning - 20' Wide - 8' Projection - 4-Layer Vinyl - Black Fade
- Shop: Dexter Bearing Kit, 15123/ 25580 Bearings, 10-36 Seal
- Shop: Kodiak Disc Brake Caliper - KodaGuard - 3,500 lbs to 6,000 lbs
- Shop: Grease Seals 10-36 (pair)
- Shop: Kodiak Disc Brake Caliper - Dacromet - 3,500 lbs to 6,000 lbs
- Shop: Kodiak Disc Brakes - 12" Hub/Rotor - 6 on 5-1/2 - Dacromet/KodaGuard - 5.2K to 6K - E-Z Lube
- Article: 4-Step Guide to Installing RV Solar Power
- Q&A: Grease Coming Out of EZ Lube Trailer Spindle
- Video: Ultimate Overview of the Kodiak Disc Brakes
- Q&A: How to Wire a 6 Pole Round Trailer End Plug
- Q&A: How Does the Wesbar Trailer Clearance or Side Marker Light with Reflector # 47-222015 Install
- Video: A Closer Look at the Replacement Bearing Buddy Bras
- Video: Checking Out the Replacement Bearing Buddy Bras
- Search Results: brake actuator cap
- Video: Review of Dexter Replacement Master Cylinder Filler Cap Dexter Dico Model 60 Aero 7500 - T4480701
- Q&A: Bearing Kit for Trailer Axle that Has Grease Seal GS-1719DL
- Q&A: Solution for Needing Replacement Parts for Atwood Surge Brake Coupler
- Search Results: trailer hubs and drums
- Search Results: l68149
- Search Results: grease
- Search Results: dust cover
- Q&A: Correct Size Carpet for 2x4 Bunk Boards on Boat Trailer
- Q&A: Rubber Piece for Cap on Titan Model 60 Actuator
- Article: Most Popular Wheel Bearings
- Shop: Trailer Hitch
on Accessories and Parts
