Available 3,500 lb Timbren Axle-Less System Without Electric Brakes

Question

Question:

do you sell this item bellow without trailer brakes? Timbren Axle-Less Trailer Suspension System w Electric Brake Hubs - 4inch Spindle - 3,500 lbs Item # A35RD545E

asked by: RYAN

0

Expert Reply:

There is a Timbren Axle-Less Trailer Suspension System similar to # A35RD545E but does not have electric brakes. The # A35RD545 has the same 3,500 lb capacity with a 4" drop spindle and idler hubs. The hubs have a 5 on 4-1/2" bolt pattern with inner bearing # L68149, outer bearing # L44649 and grease seal # RG06-050. I've added a link to a video review of the Timbren Suspension System for you to take a look at as well.

expert reply by: Kyle S

0

Answer 1

First you will need to measure to determine if you need a Timbren System with a Straight Spindle #A35RS545 or a 4" Drop Spindle #A35RD545. The straight spindle will place the axle centerline 3-13/16" below the bottom of the frame while the…

view full answer...

Answer 2

It sounds like what you are needing is a Timbren Axle-Less Suspension System that has a drop spindle on it in order to have a low clearance to fit in your garage. We do have options for you, both of which have a 4 inch drop, 3,500 lb capacity and…

view full answer...

Answer 3

We have two Timbren, 3,500 pound systems with idler hubs, the Timbren Axle-Less Trailer Suspension System with Hubs - Strait Spindle - 5 on 4-1/2 #A35RS545 and the Timbren Axle-Less Trailer Suspension with Hubs - 4 Inch Drop Spindle - 5 on 4-1/2…

view full answer...

Answer 4

In order to determine the torque rating for the lug nuts on your trailer you will need to know check out the chart I attached that shows all of the torque specs for all the trailer lugs available based on stud size, wheel material and wheel size.

view full answer...

Answer 5

According to Blue Ox, it'll take an experienced installer about 4 to 5 hours to complete the installation of their #BX1128 Base Plate Kit on a 2016 Jeep Grand Cherokee. The install isn't what I'd call super-difficult, but the installation…

view full answer...

Answer 6

It sounds like you are speaking of the wires for the brake magnets. If this is correct, you will need to connect one of the wires to the brake controller output wire on your trailer connector and the other wire will need to be grounded to a clean…

view full answer...

Answer 7

To determine the size of the brake assemblies you need you have to measure the depth and width of the hub drum on the axle like what you see in the picture I attached. The most common size is 2-1/4 inch wide like the #T4071600-500 that you…

view full answer...

Answer 8

Thank you for providing the specs for the suspension components that you already have. Correct hanger spacing really depends on the components being used such as springs, hangers and equalizers. Most of the hanger spacing dimensions that we have are…

view full answer...

Answer 9

The 5.30-12 tires, being wider, are going to make more contact with the road. This means that the noise, and heat build up will be higher than a 4.80-12 tire but the rolling resistance will actually be less because the tire is larger diameter. The…

view full answer...

Answer 10

The BTR and BT8 denotations refer to the spindle, not the trailer hub. The difference between a BTR and BT8 spindle is that the BTR spindle uses a 1.063" diameter L44649 bearing and the BT8 spindle uses a 0.99" diameter L44643 bearing. In…

view full answer...

Answer 11

Even though I cannot comment specifically on the grease you used because I am not familiar with it, I can tell you the best grease for trailer bearings is a a grease with a rating of GC-LB, which just means it is made to withstand very high…

view full answer...

Answer 12

That's a very good question, we tend to be extra cautious and say to use 10 gauge wire because that would be more than enough. When you get into longer trailers that will end up using a lot of wire the heavier gauge wire becomes more necessary.…

view full answer...

Available 3,500 lb Timbren Axle-Less System Without Electric Brakes

Products Featured in This Question

Product Page this Question was Asked From

Featured Help Information

Miscellaneous Media

Continue Researching