How to Get Wires Through The Lippert Double Flexguard RV Slide-Out Kits Brackets
Question:
How do you get the wires through the the brackets on the Lippert flex guard double kit
asked by: Ronald P
Expert Reply:
The black flex guard will slide through the longer thin hole on the brackets. There is no notch to slide your wires in, so your wires will need to be disconnected on one side or the other to feed them through the holes on the brackets.
I have attached photos of the installation instructions for the Lippert Double Flexguard RV Slide-Out Kit Hardware # LC1346281.
Installation Instructions are as follows.
1. Position Flex Guard under the slide-out room where the wiring or hoses to be protected are located.
2. Insert the aluminum pin (Fig. 1A) into the Flex Guard (Fig. 1B) with the mounting bracket (Fig. 1C)
facing up. Slide the star washer (Fig. 1D) over the end of the pin at the bottom of the Flex Guard and
push in place.
3. Slide the Flex Guard clips (Fig. 1E) onto the end of the Flex Guard with the holes in the clips facing the
direction of the hoses and wiring to hold them in place. Space all clips evenly throughout the length of
the Flex Guard.
4. Install Flex Guard mounting bracket (Fig. 1C) to the bottom of the unit floor, perpendicular to the
outrigger and furthest away from the I-beam or room bar, using four #10 x 1" self-tapping screws or
#10 x 1" wood screws (Fig. 2A).
5. Mount the flat end of the Flex Guard to the LCI-supplied mounting plate (Fig. 3A) mounted offset to
the aluminum pin (Fig. 1A) at the opposite end using two #10 x 1" self-tapping screws (Fig. 3B) per belt
section. Install the LCI-supplied mounting plate to the bottom side of the slide-out room.
6. Slide any hoses and wiring through the holes in the Flex Guard clips when installing in order to protect
hoses and wiring with the Flex Guard.
7. Flex Guard should be kept parallel to the slide room floor.
8. Make sure the flat end of the Flex Guard is mounted several inches away from the direction of the bend
of the retracted Flex Guard (Fig. 4).
(click to enlarge)
(click to enlarge)
Product Page this Question was Asked From
Lippert Double Flexguard RV Slide-Out Kit Hardware
- RV Slide Out Parts
- Hardware
- Flexguard
- Lippert
more information >
Featured Help Information
Miscellaneous Media
Continue Researching
- Video: Review of MORryde Replacement number 5 Rubber Shear Spring - MR85UR
- Shop: Tonneau Cover
- Shop: Lippert Double Flexguard RV Slide-Out Kit Hardware
- Video: Breaking Down the Lippert Components Single Flexguard RV Slide-Out Kit Hardware
- Shop: BAK Revolver X4ts Hard Tonneau Cover - Roll Up - Aluminum and Vinyl - Matte Black
- Video: Ultimate Overview of the MORryde StepAbove RV Steps for 23-3/4" to 26-1/4" Wide Doorways
- Video: Hands-On with the MORryde StepAbove RV Steps with Strut Assist
- Video: Hands-On with the Lippert 360 Siphon RV Vent Cap for Black Water Holding Tanks
- Shop: Camco Magic Chef Stove Grommets
- Shop: LaSalle Bristol RV Plumbing Roof Vent with Snap On Cap - 5-1/2" Diameter - PVC - Black
- Shop: Lippert 360 Siphon RV Vent Cap for Black Water Holding Tanks - 4-1/2" Diameter - Black
- Q&A: Installation of Lippert Flexguard RV Slide-Out Kit Hardware
- Shop: Replacement #05 Rubber Shear Spring for MORryde Rubber Pin Boxes for 14K to 18K Trailers
- Search Results: mr28rr
- Search Results: mr48rr
- Search Results: mr45rr
- Video: Lippert Double Flexguard RV Slide-Out Kit Hardware Installation - 2007 Starcraft Homestead Lite Fift
- Shop: BAK Revolver X2 Hard Tonneau Cover - Roll Up - Aluminum and Vinyl
- Video: Hydrastar Disc Brake Kit w/ Actuator for Single Axle Trailers Feature Review
- Search Results: lippert hydraulic slide~out systems rv slide out parts
- Search Results: rv stairs
- Search Results: vent cap rv vents and fans
- Search Results: rv starter kits
- Shop: RV Roof Membrane
- Q&A: Solution for Needing Lippert Components Double Flexguard Clips
- Q&A: Length of Lippert LC1346281 Double Flexguard RV Slide-Out Kit Wire Support
- Q&A: Do the Lippert Flexguards Have a Different Width?
- Q&A: Skid Height and Thickness for the Specialty Recreation Replacement Slide Out Skis
- Q&A: Availability of 15" Aluminum Jaguar Trailer Wheel
- Q&A: What is the Length of the Strip Included with Lippert Single Flexguard RV Slide-Out Kit # LC1346271
on RV Slide Out Parts
