Troubleshooting A Demco Air Force One Reed Switch That Stays On Constantly
Updated 07/24/2023 | Published 07/22/2023
Products Featured in This Question
Question:
I am installing the Air Force One braking system on my 2015 Ford F150. I just finished the truck side and installed the fuse. My reed switch is lit up and so is the indicator light on the back of my mirror. Not sure what to do I belive I have it wired the way the diagram shows.
asked by: Bob M
Expert Reply:
Most likely the reed switch on the back of the actuator is likely out of adjustment. Loosen the clamp and slide it towards the firewall of your F-150 until it goes off. Re-check calibration of the switch by depressing pedal with one hand and pulling on the back of the actuator, the light should illuminate when pulled and go off when released. If that doesn’t fix the problem re-check the wiring for your Air Force One # SM99243 and make sure it matches up to the diagram.
It is also possible that your reed switch arced to ground and is causing the light to remain on. This would need to be replaced with part # SM6245.
Product Page this Question was Asked From
Demco Air Force One Flat Tow Brake System for RVs w/ Air Brakes - Proportional
- Flat Tow Brake System
- Brake Systems
- Proportional System
- One-Time Setup
- Vehicle Battery
- Fixed System
- Power Assist Brake Compatible
- Air Brakes
- Indicator Lights
- Demco
more information >
Featured Help Information
Instructions
Continue Researching
- Shop: Vehicle Tow Bar Brake System
- Video: Demco SBS Air Force One Supplemental Braking System Installation - 2022 Jeep Grand Cherokee L
- Search Results: stop light switch flat tow brake system
- Search Results: demco reed switch
- Shop: Demco Air Force One Flat Tow Brake System for RVs w/ Air Brakes - Proportional
- Shop: Blue Ox Adjustable Drop Hitch Receiver Adapter - 2" Hitches - 8" Rise/Drop - 10,000 lbs
- Shop: Blue Ox Adjustable Drop Hitch Receiver Adapter - 2" Hitches - 4" Rise/Drop - 10,000 lbs
- Shop: Replacement LED Monitor Light for Demco Air Force One and Stay-IN-Play Duo Braking Systems
- Video: Review of Demco Air Force One/ Stay-IN-Play DUO Braking Cylinder Cable - DM56VR
- Shop: Vehicle Tow Bar Wiring
- Shop: Replacement Air Cylinder for Demco Air Force One Flat Tow Brake System
- Shop: Replacement Air Jumper for Demco Air Force One Flat Tow Brake System
- Q&A: Trouble Finding Brake Light Wire on a 2025 Ford F-150
- Video: Demco Air Force One Flat Tow Brake System for RVs w/ Air Brakes: The Breakdown
- Shop: Replacement Reed Switch with Bracket for Demco Air Force One Flat Tow Brake System
- Search Results: airforce one
- Search Results: receiver hitch extensions
- Search Results: air force one parts
- Q&A: Actuating Cylinder Replacement For Demco SBS Air Force One Supplemental Braking System
- Video: How to Choose the Right High-Low Adapter
- Video: Review of Demco Replacement LED Monitor Light Air Force One Stay-In-Play Duo Braking - SM99612
- Video: An In-Depth Look at the Roadmaster Stop Light Switch Kit
- Video: All About the Roadmaster Stop Light Switch Kit
- Q&A: Could Demco SBS G Force Controller Replace Older Model
- Q&A: Light Kit For Air Force One Supplemental Braking System
- Q&A: Troubleshooting A Demco Air Force One Braking System Indicator Light That's Always On
- Shop: Base Plate for Tow Bar
- Q&A: How to Test Reed Switch of Demco Air Force One
- Q&A: How To Wire Replacement LED Monitor Light for Demco Air Force One and Stay-IN-Play Braking System
- Search Results: diode