Solution For 7-Way Cord That Becomes Rigin In The Cold Weather
Updated 11/03/2025 | Published 01/15/2025
Products Featured in This Question
Question:
my 7-way cord gets very stiff in the cold weather and makes it almost impossible to hook up in some cases. Especially with as cold as its been recently. Any Advice or suggestions on how to remedy this?
asked by: Bob
Expert Reply:
Hey Bob, great question. It was about 7 degrees here in Missouri this morning, so I can relate to the cold. I do have a good solution for this too. What I would do is replace your current 7-way cord with the Curt Cold Weather 7-Way RV Style Connector # C23RJ. This cord is made from a flexible thermoplastic which will not become rigid in the extreme cold. It feels a bit more like soft rubber than hard plastic, even in temps as low as 40 below. Hopefully it never gets that cold here though lol.
Product Page this Question was Asked From
etrailer Trailer Wiring 7-Way Upgrade Kit w/ Junction Box and RV Style Connector
- Trailer Wiring
- Trailer Connectors
- Trailer End Connector
- 7 Blade
- Plug and Lead
- etrailer
more information >
Continue Researching
- Search Results: trailer wiring
- Search Results: 7 way cord 7 way rv
- Search Results: junction block
- Search Results: boat winch
- Search Results: optronics grommet
- Search Results: 7 pin plug
- Search Results: 7 pin trailer connector
- Shop: Curt Cold Weather 7-Way RV Style Connector - Trailer End - 10' Long - RV Standard
- Shop: etrailer Trailer Wiring 7-Way Upgrade Kit w/ Junction Box and RV Style Connector
- Shop: Mighty Cord 7-Way RV-Style Trailer Connector w/ Molded Cable - Trailer End - 10' Long
- Shop: Mighty Cord 7-Way RV Style Trailer Connector w/ Molded Cable - Trailer End - 8' Long
- Video: Review of Phoenix USA Trailer Wiring - Ten Pole Junction Box - PHX53ZR
- Shop: Trailer Wiring Junction Box - 7 Color Coded Terminals - ABS
- Shop: Phoenix USA Junction Box - 10 Pole - 12V
- Video: Review of CURT Trailer Wiring - Trailer End Cold Weather 7 Way RV Style Connector - C23RJ
- Shop: Pollak 7-Circuit-Breaker Junction Box
- Video: Complete Breakdown of the Trailer Wiring Junction Box
- Article: Trailer Wiring Diagrams
- Video: Let’s Check Out the Trailer Wiring Junction Box
- Q&A: Recommended Replacement Hand Winch for a Profile 2000
- Shop: Trailer Wiring
- Q&A: Looking For Good Quality 7-Way Trailer Side Pigtail
- Article: Is It Illegal to Leave My Hitch on My Truck?
- Video: Feature Breakdown: Empire Faucets RV Outdoor Shower Box
- Video: Phoenix Faucets RV Outdoor Shower Box Review
- Video: Ark Ezi-Guides Self-Aligning Boat Trailer Loading System Review
- Q&A: 2019 Ford F-250 Super Duty In-Bed 7-Way Socket Recommendation for Aluminum Truck Bed
- Q&A: What Gauge Wire Should be Used to Wire Trailer Brakes
- Article: Trailer Lighting Requirements
- Q&A: Can Trailer With 12,000 lb Single Axle Switch From Dual 16 Inch to 17-1/2 Inch Wheels
Jesse M.
11/3/2025
Hey Bob, how did the Curt cold weather 7-way cord work out once the temps dropped again? Your feedback could really help others dealing with stiff cords in freezing weather.