Blue Ox Patriot3 Brakes Always On Solución de Problemas Frenos del Blue Ox Patriot3 Siempre Activado  

Question:

Expert Reply:

Hello Eduardo.

I have a few questions for you.

Is this something that has recently started to happen or is this the first time you are using the Blue Ox Patriot part # BLU37TR?
Is it intermittent braking or always applying the brakes?
Is it something that happens over time while towing or from the start?
Is there any error codes or messages showing?

There are a few reasons why this could be happening. If the main unit is not sitting on the vehicle floor properly it can cause the unit to not work properly. The sensitivity setting may be too high, so normal bumps, turns, or deceleration trigger braking.

The first thing you can check would be the breakaway cable. Make sure the pin is not pulled out at all and is fully inserted into the breakaway box. Also check to make sure that the cable that connects the breakaway to the main unit is plugged in all the way. If the braking is happening after being on the road for a while it's possible that it isn't in all the way and coming out. You can check that the brake pedal fully releases, have someone use the manual override and then watch to make sure it's releasing properly. If it's not the cylinder could be getting stuck. This can happen if the main unit isn't sitting on the vehicle floor properly.

Let me know what you have found out and if you have any more questions.


(Lo siguiente fue traducido usando un traductor.)
Hola Eduardo.

Tengo algunas preguntas para ti.

¿O Esto es algo que ha empezado a suceder recientemente o es la primera vez que utilizas el Blue Ox Patriot parte # BLU37TR?
¿O El frenado es intermitente o se aplican los frenos constantemente?
¿O Sucede con el tiempo mientras remolcas o desde el principio?
¿O Aparece algún código o mensaje de error?

Hay varias razones por las que esto podría estar sucediendo. Si la unidad principal no está bien colocada en el piso del vehículo, puede que no funcione correctamente. La configuración de sensibilidad podría ser demasiado alta, por lo que los baches, giros o desaceleraciones normales activan el frenado.

Lo primero que puedes revisar es el cable de seguridad. Asegúrate de que el pasador no esté suelto y esté completamente insertado en la caja de seguridad. También verifica que el cable que conecta la caja de seguridad a la unidad principal esté bien enchufado. Si el frenado ocurre después de un tiempo en la carretera, es posible que no esté bien conectado y se esté soltando. Puedes verificar que el pedal de freno se libere por completo; pídele a alguien que use el control manual y observa si se libera correctamente. Si no es así, el cilindro podría estar atascado. Esto puede suceder si la unidad principal no está bien colocada en el piso del vehículo.

Avísame qué has descubierto y si tienes alguna otra pregunta.

expert reply by: Gwendolyn Y

0

Blue Ox Patriot 3
(click to enlarge)

Ben

12/30/2025

We installed the brake system when we started towing and have not had a problem with it. Just need to make sure it is flat on the floor, properly attached to the brake pedal. We always kept the sensitivity set at 5. We are currently selling our motorhome.

Bill

12/30/2025

I bought Blue Ox Patriot braking system. I live in Colorado, we have hills. I use it in my Jeep wrangler, towing with my motorhome. It did take a little while to get everything adjusted. Now it is quick in and out. I am very satisfied with its performance. It makes a big difference. I had no problems with reception from the jeep to the controller. This was a concern at first, being 35' apart and inside two different vehicles.

Gwendolyn Y.

12/30/2025

@Bill Thanks for giving your input, Bill. I know sometimes it can be a bit finicky when first getting everything set up.

Barry H.

12/30/2025

The only time I had any issues towing my jeep is when my battery in the jeep went bad. The jeep was least than a year old so it was unexpected. Replaced the battery and no issues. I also tow a Kia soul with no issues. Very happy with the blue ox system.

Gwendolyn Y.

12/30/2025

@BarryH Oh wow that is a short time for a battery to go bad. Hopefully the new one is lasting a lot longer than the first.