Troubleshooting 12 Volts Always Present at the Brake Output Circuit of a 7-Way
Updated 10/16/2013 | Published 10/15/2013
Question:
I just installed a 5504 on my 1997 ford F350. I was testing the wires at the trailer connector on the truck before hooking it up to the trailer. I noticed that there is 12Vdc on the brake controller output when no brakes are applied on the truck and no trailer is connected. Is this normal when there is no trailer connected? I would think there would be 0 volts until the truck brakes are applied.
asked by: Brett
Expert Reply:
You are correct, you should not be seeing voltage on the brake output circuit of your 7-way all the time. I would check the wiring of the back of the 7-way and see whats going on. It sounds like the 12 volt accessory circuit may be wired to the brake output circuit, or its shorting out to it.
I also attached an FAQ article on troubleshooting brake controller installs for you to check out as well.
Product Page this Question was Asked From
Draw-Tite Activator IV Trailer Brake Controller - Up to 4 Axles - Time Delayed
- Trailer Brake Controller
- Time Delayed Controller
- Electric
- Plug-In
- Under-Dash Box
- Under-Dash
- Up to 4 Axles
- LED Display
- Single Trailer Only
- Draw-Tite
more information >
Featured Help Information
Instructions
Miscellaneous Media
Continue Researching
- Q&A: Recommended Trailer Hitch and Wiring Harness for a 2025 Kia Sorrento Hybrid
- Q&A: Will Kodiak Trailer Hub for 3,500-lb Axles Fit Dexter 80043A Spindle On Boat Trailer
- Q&A: Help Picking Out Replacement Axle for 2004 Ranger Trail Trailer
- Q&A: Replacement Hub and Drum Assemblies for AL/KO 8460 Hubs and Drums
- Q&A: Replacing Wheels on a Trailer with 5 Spoke Utility Hubs and 8-14.5 Size Tires
- Q&A: Can 2020 Kia Soul-GT Turbo DCT be Flat Towed behind Motorhome
- Q&A: Difference Between Tekonsha 119251 and 119250 ZCI Wiring Harness for Mini Cooper
- Article: Wiring Trailer Lights with a 7-Way Plug (It's Easier Than You Think)
- Article: Brake Controller 7- and 4-Way Installation Kit (ETBC7)
- Article: Troubleshooting Brake Controller Installations
- Article: How to Measure for Travel Trailer and Fifth Wheel Steps
- Article: Double-Eye Trailer Suspension System Review
- Article: Towing a Trailer? Let's Talk About Brake Controllers
- Article: Trailer Wiring Diagrams