How to wire the Battery Isolation Solenoid # PK5231201 and what Size Wire to Use
Updated 04/20/2011 | Published 04/19/2011
Products Featured in This Question
Question:
what size wire do i need from isolator 1 from battery to isolator, 8 to 2- 6 volt golf cart batteries?
asked by: Frank B
Expert Reply:
When Using the Battery Isolation Solenoid, item # PK5231201, for isolating a vehicle 12 volt battery from the power going to a 12 volt trailer battery through the vehicle trailer connector, we use 10 gauge wire, item # 10-1-1 or # 10-2-1, depending on the wiring situation. If the solenoid were attached directly between two batteries under the hood that are hooked to the charging system, I would use battery cables, the same size as the vehicle battery uses, on the battery posts, and a 10 gauge wire from the ignition source of the vehicle. I have posted a photo detailing how the solenoid is typically wired.
I am not exactly sure what you are trying to do with the batteries on your golf cart, but the Battery Isolation Solenoid, item # PK5231201, is designed for 12 volt systems only. The voltage from the 6 volt batteries would not be high enough for use of the solenoid and could cause overheating issues.
Product Page this Question was Asked From
Starter Solenoid - SPST - 12 Volt - 100 Amp - Continuous Duty - Grounded
- Accessories and Parts
- Battery
- Switches and Solenoids
- 100 Amp
- Pollak
more information >
Continue Researching
- Shop: Starter Solenoid - SPST - 12 Volt - 100 Amp - Continuous Duty - Grounded
- Q&A: 7-Way Trailer Connector 12 Volt Circuit has Power All the Time
- Q&A: How to Wire Up the 12 Volt Accessory Circuit of a 7-Way Connector
- Q&A: Will Installing the ETBC7 Universal Trailer Brake Connector Cause Vehicle Battery to Drain
- Q&A: Does 12V Pin on 7-way Trailer Connector Always Have Power
- Q&A: My Owners Manual is Saying to Not Install a Hitch, but You Have One Listed to Work, What Should I do
- Q&A: How to Turn Off 12-V Power Feed to 7-Way Trailer Connector on Vehicle When Ignition is Shut Off
- Q&A: How to Find Replacement for 4 Lug Hubs on Utility Trailer
- Article: How to Accurately Measure Trailer Leaf Springs
- Article: Trailer Wiring Diagrams
- Article: Brake Controller 7- and 4-Way Installation Kit (ETBC7)
- Article: Brake Controller Installation on a Full-Size Ford Truck or SUV
- Article: How to Charge a Trailer Battery While Driving: 3 Common Problems (And How to Fix Them)
- Article: How Many Batteries Do You Need to Run an RV Air Conditioner?
- Article: How to Troubleshoot Your RV Air Conditioner